Zircon Breaker ID - Instructions Manual

CIRCUIT FINDER
Breaker ID
CIRCUIT FINDER RECEIVER
Breaker ID
Circuit Breaker Finder
1. EQUIPMENT RATINGS
•110–120VAC,60Hz,3wmaximum.
•Thisdevicepossesesasingleinput/outputconnectiondesigned
toplugintoastandardU.S.outlet.
•Thisdeviceisforindooruseonly.
Ifthedeviceisusedinamannernotspeciedhere,thenthe
protectionprovidedbythedevicemaybeimpaired.
Nopartofthisdevicemaybereplacedorrepairedbyanyone
exceptthemanufacturer.
Technicalassistance:1-800-245-9265,info@zircon.com,
orwww.zircon.com.
2. INSTALLING THE BATTERY
Lifttabonbottomendofcliptoreleaseendcap.
Slide9-Vbatteryintocompartment,terminalside
rst,matching(+)and(-)terminalsfrombattery
tocase.
Slidethecliponto
thereceiver,pressing
downonbattery
untilbothpieces
snaptogether.
3. LOCATING A CIRCUIT
Note: A small percentage of circuit boxes are mounted
with breakers oriented vertically. See diagrams for
proper receiver orientation.
Warning: For indoor use only on standard 110–120 V
AC outlets.
Plugthetransmitterintotheoutletthatneedstobeturnedoff.
VerifythattheredLEDglows,indicatingalivecircuit.
Gotothecircuitpanel.Turnonthereceiver
andholditagainstthebreakerasshown.
5. HELPFUL HINTS
Itisimportanttoholdthereceiveratananglesothattheentire
CONTACTAREAofthereceivertoucheseachcircuitbreaker.
Slowlyscanthereceiveroverallbreakers.Thiscalibratestheunit.
Duringthisrstpasswhiletheunitiscalibrating,thereceiver
mayindicatemorethanonebreaker.Thisisnormal.Ifyouhave
morethanonepanel,besuretoperformthissteponeachpanel.
Donotturnoffthereceiver.
Perform a second pass over the breakers. Whenthegreen
LEDglowsandthebuzzersounds,youaredirectlyoverthe
breakerconnectedtothetransmitter.
Turnoffthebreaker.
VerifythattheredLEDonthetransmitterisoff,indicatingadead
circuit,beforebeginningwork.
4. CLEANING AND STORING THE UNIT
Cleantransmitterwithdryclothonly.Donotexposeproduct
toliquids.
Snapthetransmitterandreceivertogetherforstorage.
Situation Probable Causes Solutions
Noindication,i.e.,no
greenLEDandbuzzer.
Multipleindicationson
secondscan.
Tracingcircuitconnected
tolightxture.
Receiverindicates
breakerabovethe
correctone.
Thebreakerforthatcircuitis
notintheboxbeingscanned.
Therstscanwasperformed
tooquickly.
Receiverisheldhorizontally
withonlythetipofthereceiver
contactingthebreakerand
notanangle(seeillustration
inStep3).
Scantheboxthatsupplies
thatcircuit.
Scanagain,movingthereceiver
slowly.Besuretokeepthenoseof
thereceiverclosetothebreaker
andmaintainproperorientation.
Useanoutletadapter.Screwthe
adapterintothesocket,thenplug
thetransmitterintoit.Orplugan
extensioncordintotheadapter,
thenplugthetransmitterintothe
extensioncord.
Holdthereceiveratanangleso
theentireCONTACTAREAof
thereceivertoucheseachcircuit
breaker(seeillustrationinStep3).
LIMITED 1 YEAR WARRANTY
ZirconCorporation,(“Zircon”)warrantsthisproducttobefreefromdefectsinmaterialsandworkmanship
foroneyearsfromthedateofpurchase.Anyin-warrantydefectiveproductreturnedtoZircon*,freight
prepaidwithproofofpurchasedateand$5.00tocoverpostageandhandling,willberepairedorreplaced
atZircon’soption.Thiswarrantyislimitedtotheelectroniccircuitryandoriginalcaseoftheproduct
andspecificallyexcludesdamagecausedbyabuse,unreasonableuseorneglect.Thiswarrantyisinlieu
ofallotherwarranties,expressorimplied,andnootherrepresentationsorclaimsofanynatureshall
bindorobligateZircon.Anyimpliedwarrantiesapplicabletothisproductarelimitedtotheoneyear
periodfollowingitspurchase.INNOEVENTWILLZIRCONBELIABLEFORANYSPECIAL,INCIDENTALOR
CONSEQUENTIALDAMAGESRESULTINGFROMPOSSESSION,USEORMALFUNCTIONOFTHISPRODUCT.
Inaccordancewithgovernmentregulations,youareadvisedthat:(i)somestatesdonotallowlimitations
onhowlonganimpliedwarrantylastsand/ortheexclusionorlimitationofincidentalorconsequential
damages,sotheabovelimitationsand/orexclusionsmaynotapplytoyou,andfurther(ii)thiswarranty
givesyouspecificlegalrightsandyoumayalsohaveotherrightswhichvaryfromstatetostate.
Returnproductfreightprepaidwithproofofpurchasedate(datedsalesreceipt)and$5.00tocoverpostage
andhandling,to:
ZirconCorporation
*Attn:ReturnsDepartment
1580DellAvenue
Campbell,CA95008-6992USA
Besuretoincludeyournameandreturnaddress.Outofwarrantyserviceandrepair,whereproofof
purchaseisnotprovided,shallbereturnedwithrepairschargedC.O.D.Allow4to6weeksfordelivery.
CustomerService,1-800-245-9265or1-408-963-4550
Monday–Friday,8:00a.m.to5:00p.m.PDT
www.zircon.com•info@zircon.com
U.S.Patents6291970and6933712,CanadianPatent2353156andPatentPending,E.U.PatentPending
©2010ZirconCorporation•P/N64267•RevA04/10
Visit www.zircon.com/support
for the most current instructions.
ZirconisaregisteredtrademarkofZirconCorporation.
Locatingabreakerwhenyouhavetoturnoffacircuitcanbea
realproblem.Taketheguessworkoutofndingtherightbreaker.
YES NO
Transmitter Receiver
GreenLED
RedLED
RedLED
VerticalBreakers
VerticalBreakers
HorizontalBreakers
HorizontalBreakers
OrientationLabelUndersideofReceiver
ON/OFF