Home
A.O. Smith
Water Heater
AHPW-25
A.O. Smith AHPW-25 Installation & Service Manual
4
of 1
of 1 rating
44 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
14
3
Hydronic piping
DIR #2000577549
HOT
WA
TER SUPPL
Y
BOILER
WA
TER IN
BOILER
WA
TER
OUT
COLD
WA
TER SUPPL
Y
BYP
ASS LINE
Figure 3-7
Multiple Units with Conventional Heating System as a Zone
Please note that these illustrations are meant to show system piping concept only, the installer is responsible
for all equipment and detailing required by local codes.
NOTICE
Indirect Plate Water Heater Installation & Service Manual
13
15
Table of Contents
Hazard Definitions
2
Table of Contents
2
Please Read before Proceeding
3
The APW - How It Works
4
1 Determine Apw Location
5
Before Locating the Appliance, Check
5
Site Selection and Preparation
5
Installation Clearances
5
APW Water Heater Clearances
6
2 Prepare Water Heater
7
Receiving and Unpacking the APW
7
Setting the Unit
7
3 Hydronic Piping
8
APW Piping Assemblies
8
General Piping Information
8
Heating Fluid and Domestic Hot Water (DHW) Piping
8
Scalding
8
Hydronic Piping Illustrations
9
4 Adjustments
15
3-Way Control Valve Adjustment
15
Control Valve Calibration and Status Indications
15
Manual Control of 3-Way Valve
16
Temperature Controller Operating Controls
18
5 Operating Information
19
Sequence of Operation
19
Electronic Control Overview
19
Over-Temperature Control and Safety Features
19
6 Wiring
20
Electrical Wiring Connections
20
7 Modbus
21
Installation Procedure
21
Modbus Eexception Codes
22
Primary Data Tables
23
Memory Map
23
Physical Wiring
23
Procedure to Change Modbus Address
24
Troubleshooting
24
8 START-UP Introduction
25
Pre-Operational Checks and Procedures
25
Initial Start-Up
25
Checking Mixed Inlet Temperature
26
Shutting down the System
26
9 MAINTENANCE Maintenance and Annual Startup
27
Periodic Cleaning of Heat Exchanger
28
Strainers - Inspection and Replacement
28
Oiled Bearing Circulators
28
Check Water Heater Relief Valve
28
10 Troubleshooting
29
Checking Temperature Sensors
30
11 Sizing Data
31
How to Properly Size Your Indirect Water Heater
31
12 Diagrams
39
Wiring Diagram
39
13 Replacement Parts List
40
When Ordering Replacement Parts
40
Revision Notes
44
Other manuals for A.O. Smith AHPW-25
Instruction Manual
120 pages
Installation And Operating Manual
56 pages
Service Handbook
84 pages
User's Information Manual
44 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the A.O. Smith AHPW-25 and is the answer not in the manual?
Ask a question
A.O. Smith AHPW-25 Specifications
General
Brand
A.O. Smith
Model
AHPW-25
Category
Water Heater
Language
English
Related product manuals
A.O. Smith AHPM-270
120 pages
A.O. Smith AWH-35
48 pages
A.O. Smith ATX-199
76 pages
A.O. Smith ADM - 40
70 pages
A.O. Smith APW015DW
120 pages
A.O. Smith ARGSS02708
36 pages
A.O. Smith ATI-140H-N
64 pages
A.O. Smith ATI-540H-N
64 pages
A.O. Smith AOS GPHE-50
4 pages
A.O. Smith BTH 120-250(A)
32 pages
A.O. Smith 100 Series
120 pages
A.O. Smith Water Heater
36 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
