Acer Iconia A1-810 - CHAPTER 3 Machine Maintenance; Machine Disassembly and Replacement; Recommended Equipment; Replacement Requirements

2
CHAPTER 3
Machine Maintenance
Machine Disassembly and Replacement. . . . . . . . . . . . . . . . . . . 3-3
Recommended Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Replacement Requirements. . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
Pre-disassembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
Disassembly Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Disassembly Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-5
Removing the MicroSD Card . . . . . . . . . . . . . . . . . . . . . . . . . .3-6
Removing the Back Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-7
Removing the Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-10
Removing the GPS and WLAN Antenna Cables . . . . . . . . . . .3-11
Removing the Vibration Motor Module . . . . . . . . . . . . . . . . .3-13
Removing the Speaker Module. . . . . . . . . . . . . . . . . . . . . . . .3-14
Removing the Audio and USB Boards. . . . . . . . . . . . . . . . . . .3-15
Removing the Rear Camera Module . . . . . . . . . . . . . . . . . . . .3-18
Removing the Mainboard . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-19
Removing the Front Camera Module . . . . . . . . . . . . . . . . . . .3-22
Removing the LCD and Middle Frame Assembly . . . . . . . . . .3-23
Reassembly Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-24
Replacing the Front Camera Module . . . . . . . . . . . . . . . . . . .3-24
Replacing the LCD and Middle Frame Assembly . . . . . . . . . .3-25
Replacing the Mainboard . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-26
Replacing the Rear Camera Module . . . . . . . . . . . . . . . . . . . .3-29
Replacing the Audio and USB Boards . . . . . . . . . . . . . . . . . . .3-30
Replacing the Speaker Module . . . . . . . . . . . . . . . . . . . . . . . .3-33
Replacing the Vibration Motor Module . . . . . . . . . . . . . . . . .3-34
Replacing the GPS and WLAN Antenna Cables . . . . . . . . . . .3-35
Replacing the Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-37
Replacing the Back Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-39
Replacing the MicroSD Card . . . . . . . . . . . . . . . . . . . . . . . . . .3-41
CHAPTER 4
Troubleshooting
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
Power On Issues . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4
No Display Issues. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5