QUICK-SILVER™ Trouble Shooting Guide
7KLVJXLGHLVSURYLGHGDVDJHQHUDOUHIHUHQFHWRSRVVLEOHSORZIDLOXUHV3OHDVHUHPHPEHUWRFRQWDFW
7KLVJXLGHLVSURYLGHGDVDJHQHUDOUHIHUHQFHWRSRVVLEOHSORZIDLOXUHV3OHDVHUHPHPEHUWRFRQWDFW7KLVJXLGHLVSURYLGHGDVDJHQHUDOUHIHUHQFHWRSRVVLEOHSORZIDLOXUHV
3OHDVHUHPHPEHUWRFRQWDFW
7KLVJXLGHLVSURYLGHGDVDJHQHUDOUHIHUHQFHWRSRVVLEOHSORZIDLOXUHV3OHDVHUHPHPEHUWRFRQWDFW
\RXUORFDO$LU
\RXUORFDO$LU\RXUORFDO$LU
\RXUORFDO$LU
)OR
)OR)OR
)OR
4XLFN6LOYHU
4XLFN6LOYHU4XLFN6LOYHU
4XLFN6LOYHU
™'HDOHUIRUIDFWRU\RULJLQDOSDUWVDQGWUDLQHGVHUYLFH
'HDOHUIRUIDFWRU\RULJLQDOSDUWVDQGWUDLQHGVHUYLFH'HDOHUIRUIDFWRU\RULJLQDOSDUWVDQGWUDLQHGVHUYLFH
'HDOHUIRUIDFWRU\RULJLQDOSDUWVDQGWUDLQHGVHUYLFH
CONDITION
CONDITIONCONDITION
CONDITION
POSSIBLE CAUSE
POSSIBLE CAUSEPOSSIBLE CAUSE
POSSIBLE CAUSE CORRECTION
CORRECTIONCORRECTION
CORRECTION
Motor does not run.
1) Snow plow harness not connected.
2) Fuses are blown.
3) Cab control malfunction or fault in wiring.
1) Properly connect all wire harnesses.
2) Replace fuses.
3) See an Air-Flo dealer for repair information.
Motor will not shut off.
Motor relay or cab control malfunction or
fault in wiring.
See an Air-Flo dealer for repair information.
Snowplow will not raise or raises slowly or par-
tially.
1) Excesses weight on the blade and A-
frame.
2) Hydraulic Fluid level low or incorrect fluid
is used.
3) Fuses are blown.
4) Truck battery weak or malfunction in
charging system.
5) Motor worn or damaged or fault in wiring.
6) Pump filter clogged, worn or damaged
pump, or hydraulic system malfunction.
1) Remove built up snow and ice or any after
market accessories
2) Fill reservoir to proper level with recom-
mended fluid.
3) Replace fuse.
4) Replace battery and/or check charging sys-
tem.
5) See an Air-Flo dealer for repair information.
6) See an Air-Flo dealer for repair information.
manual-final.qxd 11/17/2006 12:45 PM Page 40
To Next Page
Loading...