Air King AV Series - User Manual

READ AND SAVE THESE INSTRUCTIONS
READ CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE, INSTALL, OPERATE OR MAINTAIN THE PRODUCT DESCRIBED. PROTECT
YOURSELF AND OTHERS BY OBSERVING ALL SAFETY INFORMATION. FAILURE TO COMPLY WITH
INSTRUCTIONS COULD RESULT IN PERSONAL INJURY AND/OR PROPERTY DAMAGE!
RETAIN INSTRUCTIONS FOR FUTURE REFERENCE.
GENERAL SAFETY INFORMATION
When using electrical appliances, basic precautions
should always be followed to reduce the risk of fire,
electric shock and injury to person, including the following:
WARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK
AND INJURY TO PERSON, OBSERVE THE FOLLOWING:
1. Read all instructions before installing or using range hood.
2. Use this unit only in the manner intended by the manufacturer. If
you have questions, contact the manufacturer.
3. Before servicing or cleaning the unit, switch power off at service
panel and lock the service disconnecting means to prevent power
from being switched on accidentally. When the service
disconnecting means cannot be locked, securely fasten a prominent
warning device, such as a tag, to the service panel.
4. Installation work and electrical wiring must be done by qualified
person(s) in accordance with all applicable codes and standards,
including fire-related construction.
5. Sufficient air is needed for proper combustion and exhausting of
gases through the flue (chimney) of fuel burning equipment to
prevent back drafting. Follow the heating equipment manufacturer’s
guideline and safety standards such as those published by the
National Fire Protection Association (NFPA) and the American
Society for Heating, Refrigeration, and Air Conditioning Engineers
(ASHRAE), and the local code authorities.
CAUTION: FOR GENERAL VENTILATING USE ONLY. DO NOT USE
TO EXHAUST HAZARDOUS OR EXPLOSIVE MATERIALS AND VAPORS.
6. When cutting or drilling into wall or ceiling, do not damage electrical
wiring and other hidden utilities.
CAUTION: TO REDUCE THE RISK OF FIRE AND TO PROPERLY
EXHAUST AIR, BE SURE TO DUCT AIR OUTSIDE - DO NOT VENT
EXHAUST AIR INTO SPACES WITHIN WALLS OR CEILINGS OR INTO
ATTICS, CRAWL SPACES, OR GARAGES.
7. This unit must be grounded.
8. To avoid motor bearing damage and noisy and/or unbalanced
impellers, keep drywall spray, construction dust, etc. off power unit.
AV Series
6728002 Rev. E 1-07
Range Hood
SAVE THESE INSTRUCTIONS
WARNING: TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, DO
NOT USE THIS FAN WITH ANY SOLID-STATE SPEED CONTROL DEVICE.
WARNING: TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:
a) Never leave surface units unattended at high settings. Boilovers
cause smoking and greasy spillovers that may ignite. Heat oils
slowly on low or medium settings.
b) Always turn hood ON when cooking at high heat or when
flambéing food (ie. Crepes Suzette, Cherries Jubilee, Peppercorn
Beef Flambé).
c) Clean ventilating fans frequently. Grease should not be allowed
to accumulate on fan filter.
d) Use proper pan size. Always use cookware appropriate for the
size of the surface element.
WARNING: TO REDUCE THE RISK OF INJURY TO PERSONS IN
THE EVENT OF A RANGE TOP GREASE FIRE, OBSERVE THE FOLLOWING:
a) SMOTHER FLAMES with a close-fitting lid, cookie sheet, or
metal tray, then turn off burner. BE CAREFUL TO PREVENT
BURNS. If the flames do not go out immediately, EVACUATE
AND CALL THE FIRE DEPARTMENT.
b) NEVER PICK UP A FLAMING PAN - You may be burned.
c) DO NOT USE WATER, including wet dishcloths or towels - a
violent steam explosion will result.
d) Use an extinguisher ONLY if:
I. You know you have a Class ABC extinguisher, and you already
know how to operate it.
II. The fire is small and contained in the area where it started.
III. The fire department is being called.
IV. You can fight the fire with your back to an exit.
WARNING: TO REDUCE THE RISK OF FIRE, USE ONLY METAL
DUCTWORK.
IMPORTANT INSTRUCTIONS -
OPERATING MANUAL
1
RPM
WATTS
160 Range Hood
HVI PERFORMANCE VERTICAL DUCTING
:: rangehoods
. com Call 1-800-667-8721 anywhere in the US and Canada - www.rangehoods.com
Air King at ::rangehoods.com is a division of kitchen::accessories

Summary

IMPORTANT INSTRUCTIONS OPERATING MANUAL

General Safety Information

Basic precautions for electrical appliances to reduce risks.

Specific Safety Warnings

Critical warnings regarding fire, shock, injury, and proper usage.

Ducting and Material Safety

Cautions on ducting air outside and using metal ductwork for fire prevention.

INSTALLATION INSTRUCTIONS

Prepare the installation location

Instructions for preparing the mounting area, including support strips.

Prepare the hood for installation

Steps to prepare the hood for installation, including ducting options.

Electrical Safety Before Installation

Safety caution to switch off power before starting installation.

Installing the Range Hood

Step-by-step guide for physically installing the range hood.

Installation Details

Wiring Connections

Instructions for making electrical connections according to codes.

Ducting Connections

Instructions for connecting ductwork according to codes and safety.

Finishing the Installation

Final steps for installation, including filter placement.

Operation and Maintenance

Operating Controls

Explanation of the rocker switches for light and fan operation.

Maintenance Procedures

Procedures for maintaining the range hood, including cleaning and filter care.

Filter Care

Details on cleaning the grease filter and replacing the charcoal filter.

Cleaning the Range Hood

Guidelines for cleaning the range hood safely and effectively.

Troubleshooting and Warranty

Troubleshooting Common Issues

Guide to identify and resolve common operating problems.

Product Limited Warranty

Details of the product warranty, coverage, and claim process.

Replacement Parts Diagram

Air King AV Series Specifications

General

Brand	Air King
Model	AV Series
Category	Ventilation Hood
Language	English