AJS G2 - Air Filter

Oil tank
Tyres
Oil tank/Reservoir
Ignition
Gear box
Chaincase
Battery
Oil tank/Reservoir
Rear chain
Gear box
Hubs
Expanders
Steering head
Small parts
Chaincase
Air filter
Oil Reservoir
Filter
Rear chain
Brake pedal
Speedometer
Ignition
Plug
Steering head
Bolts and nuts
Rockers
Oil tank
WEEKLY
Check level and top-up if necessary.
Check pressures and inflate if necessary.
EVERY 500 MILES
Drain at first 500 miles, re-fill with new oil and clean
filter.
Check contact breaker points.
Drain at first 500 miles and re-fill.
Check level of oil when machine is standing verti-
cally on level ground. Fill up if level is low. (See
chain lubrication.)
Inspect each cell for level of electrolyte and top up
with distilled water if necessary. Level of electro-
lyte should be just over top of plates. Beware of
overfilling.
EVERY 1,000 MILES
Drain at first 1,000 miles and re-fill with new oil.
In wet weather remove and soak in molten grease,
Check oil level.
Inject small amount of grease
Inject small amount of grease
Inject small amount of grease
Smear all moving parts with engine oil and wipe off
surplus,
Drain, and re-fill, or monthly.
EVERY 2,000 to 5,000 MILES
(according to road conditions)
(If fitted) clean and re-oil filter element.
EVERY 3,000 MILES
(Lightweight models) drain and re-fill with new oil.
If machine is used for short journeys, renew oil
every 3 months.
(Lightweight models) clean filter in crankcase.
In dry weather remove and soak in molten grease.
Inject small amount of grease.
Inject small amount of grease into speedometer
gear box, if fitted with grease nipple.
Clean contact breaker points and re-set if necessary.
Clean sparking plug and re-set points as necessary.
Test steering head for up and down movement and
adjust if necessary.
Check all nuts and bolts for tightness and tighten if
necessary but beware of over-tightening.
Check OHV rocker adjustment and correct if neces-
sary.
EVERY 5,000 MILES
(Heavyweight models) drain and re-fill with new oil.
If machine is only used for short runs renew oil
every three months instead of mileage interval.
where provision
is made
}
22
www.ajs-matchless.info