Amerec F12 - User Manual

WARNING
Do not take a sauna if using
alcohol, drugs or medications.
Pregnant women or persons with
poor health should consult their
physician before using any Sauna.
Caution fire hazard: Do not use
the Sauna room for drying
clothes, bathing suits, etc. Do not
hang towels above heater or place
any object other than the rocks
supplied on the heater. If any
darkening of the wall around the
heater is noticed discontinue
sauna use immediately.
Inspect Sauna regularly for
required maintenance to heater,
controls and benches. Replace
wood surfaces which show any
signs of deterioration.
The heater gets extremely hot
during operation and should not
be touched or burns may result.
Minors should be adequately
supervised whenever near a hot
or warming sauna.
Fire sprinkler systems used inside
any sauna room should be
properly rated for sauna room
temperatures.
Do not pour chlorinated pool or
spa water on heater. Excessive
water use on heater may cause
damage and void warranty.
Electric Shock Hazard - High
voltage exists within this
equipment. There are no user
serviceable parts in this
equipment. All installation and
service to this equipment should
be performed by qualified
licensed personnel in accordance
with local and national codes.
IIVAMEREC INSTALLATION AND SERVICE INSTRUCTIONS
///// PRODUCTS
"
//AMERED
AMEREC SAUNA HEATER
FREE STANDING FLOOR MODELS F12,
110 F15, F9-3, F12-3, F15-3
Read all instructions carefully before installation. Please leave all
instructions and warranty with the owner. Please fill out and return
your warranty certificate promptly.
WARNING
Prolonged exposure to elevated temperatures is capable of inducing hyperthermia.
Hyperthermia occurs when the internal temperature of the body reaches several
degrees above the normal body temperature of 98.6°F. The symptoms of hyperther-
mia include an increase in the normal temperature of the body, dizziness. lethargy,
drowsiness, and fainting. The effects of the hyperthermia include failure to perceive
heat, failure to recognize the need to exit the room, unawareness of impending
hazard, fetal damage in pregnant women, physical inability to exit the room and
unconsciousness.
WARNING
The use of alcohol, drugs, or medication is capable of greatly increasing the risk of
fatal hyperthermia
SECTION 1: GENERAL INFORMATION
AMEREC
Sauna heaters are listed by Underwriters Laboratories. These heaters are for permanent
installation and electrical connection. To determine the correct wire size, circuit protection and
minimum spacing from wooden surfaces, refer to the Heater Specification Chart on the following
page.
4211 -
04 2/97

Summary

General Information and Safety Precautions

Health and Usage Warnings

Covers hyperthermia risks, effects of alcohol/drugs, and advice for pregnant women and those with poor health.

Operational Safety and Hazards

Details fire hazards, electrical safety, handling of heater, supervision of minors, and proper water use.

Securing Heater to Floor

Floor Mounting Instructions

Details using angle brackets and screws for floor mounting, observing clearances.

Sauna Rocks

Rock Installation and Preheat Procedure

Explains filling the compartment, preheating rocks, and potential hazards from moisture.

Electrical Wiring

Wiring Standards and Requirements

Covers licensed contractors, wire size, circuit protection, and grounding per NEC.

Temperature Control

Thermostat Installation and Capillary Tube

Describes mounting the control box, capillary tube routing, and bulb placement.

Reset Button

Overheat Safety Device Operation

Explains the overheat safety device and how to reset the heater after tripping.

Electrical Outlets or Receptacles

Sauna Room Electrical Fixture Guidelines

Prohibits electrical outlets and specifies approved types for lighting and intercoms.

Heater Guard Rail

Guard Rail Installation Requirements

Mandates a guard rail to prevent contact with the heating unit, specifying minimum clearances.

Placards

Required Placard Placement

Details the mandatory placement of caution and warning placards for user safety.

Thermometer;Humidity Gauge

Gauge Placement Recommendation

Advises on locating the gauge 6 inches down from the ceiling for visibility.

Bucket and Dipper

Accessory Usage and Caution

Notes availability and cautions against using pool/spa water on the heater.

Room Construction

Wall, Ceiling, and Finish Specifications

Recommends materials, framing, insulation, and interior finish for sauna rooms.

Bench and Door Requirements

Specifies materials for benches and requirements for the sauna door.

Ventilation Openings

Provides guidelines for inlet and outlet ventilation opening sizes based on room area.

Operating Instructions

Initial Heater Operation and Break-in

Guides first-time users on initial heating cycles to burn off excess oil.

Setting Temperature and Timer

Explains how to set temperature controls and use the timer for optimal sauna experience.

Maintenance

General Cleaning and Odor Control

Advises on regular cleaning of the sauna room, benches, and duckboard.

Rock Cleaning and Replacement

Recommends cleaning rocks annually and replacing any small or crumbled rocks.

Bench and Support Inspection

Stresses annual inspection of benches for deterioration and timely replacement.

Amerec F12 Specifications

General

Brand	Amerec
Model	F12
Category	Heater
Language	English