AMF-BRUNS Alu Ramp - User Manual

Other manuals for AMF-BRUNS Alu Ramp

Brief Operating Instructions2 pages

Questions and Answers

S
Sarah PhillipsAug 3, 2025
What to do if my AMF-BRUNS Alu Ramp Mobility Aid vehicle does not lower?
- A
  Angela ColemanAug 3, 2025
  If your AMF-BRUNS Mobility Aid vehicle isn't lowering, the issue might stem from several causes. First, a blown 100 A fuse could be the culprit; try replacing it. Alternatively, the vehicle's battery might be discharged or defective, requiring a recharge or replacement. A low hydraulic reservoir could also be the problem; top it up with ATF fluid, being careful not to overfill. Finally, a defect in the electrical or hydraulic system may be the cause, necessitating a check by a specialist workshop.
S
Shawn LeonAug 9, 2025
Why can't I pull out the electrically operated belts on my AMF-BRUNS Alu Ramp Mobility Aid?
- S
  smithjackAug 10, 2025
  If the electrically operated belts on your AMF-BRUNS Mobility Aid cannot be pulled out, there are a few potential reasons. The rocker switch may be defective, requiring replacement. Alternatively, the fuse might have blown; replace it, locating it in the vicinity of the battery. Finally, the electrically operated belts themselves could be defective, in which case they should be replaced.
C
Christian BarnesAug 15, 2025
What to do if my AMF-BRUNS Mobility Aid vehicle lowers but raises again slowly?
- A
  Andrew WigginsAug 15, 2025
  If your AMF-BRUNS Mobility Aid vehicle lowers but raises again slowly, it could be due to several reasons. Leaking seals on the hydraulic cylinders could be the cause, requiring replacement by a specialist workshop. Another possibility is a leaking lowering valve, which would also need replacement by a specialist. Lastly, check the hydraulic reservoir; if it's empty, top it up with ATF fluid, being careful not to overfill.
M
Meagan GallowayAug 21, 2025
How to fix a ramp that does not deploy or stow correctly on AMF-BRUNS Alu Ramp Mobility Aid?
- E
  ewilliamsAug 21, 2025
  If the ramp on your AMF-BRUNS Mobility Aid isn't deploying or stowing correctly, start by inspecting the latching mechanisms for any foreign objects that might be blocking them. Remove any obstructions and clean the mechanisms if necessary. Also, check the spring-loaded latches for defects and replace them if needed. Finally, examine the gas pressure strut and replace it if it's defective.
O
owangAug 27, 2025
What to do if my AMF-BRUNS Mobility Aid vehicle does not raise?
- K
  Kyle CastroAug 27, 2025
  If your AMF-BRUNS Mobility Aid vehicle isn't raising, the lowering valve may be jammed or defective. In this case, have the lowering valve cleaned or replaced in a specialist workshop.

Summary

Foreword

Explanation of Symbols and Signs

Meaning of Directions

Safety

Proper Use

Defines correct usage for the Alu Ramp and suspension.

Improper Use

Lists prohibited actions and incorrect applications of the ramp and suspension.

Personnel Requirements

Specifies qualifications and training for operating personnel.

Product Monitoring

Instructions for reporting faults and requesting guarantee work.

Danger Zone

Identifies hazardous areas during ramp deployment.

Safety Devices

Details the function and operation of safety features like belts.

Safety and Accident Prevention Regulations

Outlines crucial rules for safe operation and maintenance.

Disposal

Guidance on proper disposal of the equipment.

Description

Layout and Function

Overview of the ramp's physical arrangement and how it operates.

Ramp

Details the two available versions of the Alu Ramp.

Floor section

Describes the floor section for wheelchair placement and headroom.

Belts and belt anchorages

Explains the function and attachment of seat belts and anchor points.

Hydraulic Lowering Rear Suspension

Details the function of the suspension system for lowering the vehicle.

Rating Plate

Information on the data plate attached to the hydraulic aggregate.

Operating Controls

Identifies and explains the purpose of various control elements.

Technical Data

Provides specifications for the Alu Ramp and suspension system.

Transportation

Installation; Commissioning

Risk of Injury from Incorrect Installation

Warns of severe risks associated with improper installation procedures.

Installation by Specialist Personnel

Emphasizes the need for trained professionals for installation.

Technical Expert Inspection

Requires inspection by a technical expert to ensure correct installation and safety.

Operation

Safety Regulations for Operation

Crucial safety rules to follow before and during operation.

General Operating Precautions

Covers essential safety warnings for operating the system safely.

Deploying the Ramp

Step-by-step guide on how to extend the ramp for use.

Embarking a Passenger;Loading a Wheelchair

Detailed steps for safely boarding a person in a wheelchair.

Disembarking a Passenger;Unloading a Wheelchair

Detailed steps for safely disembarking a person in a wheelchair.

Maintenance and Repair

Safety Regulations for Maintenance and Repair

Safety guidelines for performing maintenance and repairs on the system.

Routine Maintenance Work

Lists scheduled maintenance tasks and their frequency.

Functionally Testing the Electrically Operated Belts

Procedure for testing the functionality of the electric seat belts.

Yearly Inspection

Requirements and scope for annual inspections by a technical expert.

Maintenance and Inspection Record

Template for recording maintenance and inspection activities.

De-Commissioning and Conservation

Faults and Troubleshooting

Alu Ramp

Lists common faults related to the ramp and their solutions.

Lowering Rear Suspension

Lists common faults related to the suspension system and their solutions.

Inspection Log

Definition of a Technical Expert

Defines the qualifications and expertise of a technical inspector.

Inspection Log Master Data Sheet

Forms for recording master data of the ramp and suspension.

Inspection List

Checklist items for technical inspections of the system.

Inspection Results

Forms for documenting inspection results before and after commissioning.

Electrical Circuit Diagram

Hydraulic Circuit Diagram

Customer Service

AMF-BRUNS Alu Ramp Specifications

General

Brand	AMF-BRUNS
Model	Alu Ramp
Category	Mobility Aid
Language	English

Related product manuals

AMF-BRUNS EURO RAMP

32 pages