2003 CCN 99449712
& (419) 636-4242 FAX (419) 633-1674
INGERSOLL-RAND COMPANY
P.O. BOX 151 ONE ARO CENTER BRYAN, OHIO 43506Ć0151
OPERATOR’S MANUAL
66605X-X
RELEASED: 4-15-87
REVISED: 11-24-03
(REV. AL)
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
1/2” DIAPHRAGM PUMP
1:1 RATIO (NON-METALLIC)
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
It is the responsibility of the employer to place this information in the hands of the operator. Keep for future reference.
SERVICE KITS
Refer to Model Chart to match the pump material options.
637140ĆXX for fluid section repair (see page 4).
637141 for air section repair (see page 6).
PUMP DATA
Models See Model Description Chart for ĆXXX".. . . . . . . . . .
Pump Type NonĆMetallic Air Operated Double Diaphragm. . . . . . .
Material See Model Description Chart.. . . . . . . . . .
Weight Polypropylene 7.2 (3.3 kgs). . . . . . . . . . . . .
Groundable Acetal 8.8 (4.0 kgs). . . . . .
P.V.D.F. (Kynar) 9.5 (4.3 kgs). . . . . .
Maximum Air Inlet Pressure 100 p.s.i.g. (6.9 bar). . . . . . . . .
Maximum Material Inlet Pressure 10 p.s.i.g. (0.69 bar). . . . .
Maximum Outlet Pressure 100 p.s.i.g. (6.9 bar). . . . . . . . . .
Air Consumption 1 c.f.m. / gallon (approx.). . . . . . . . . . . . . . . . .
Maximum Flow Rate (Ball) 13 g.p.m. (49.2 l.p.m.). . . . . . .
(Duckbill) 10 g.p.m. (37.9 l.p.m.). . . .
Maximum Particle Size (Ball) 3/32" dia. (2.4 mm). . . . . . .
(Duckbill) Fibers. . . .
Maximum Temperature Limits
E.P.R. Ć60 to 280 F (Ć51 to 138 C). . . . . . . . . . . . . . . .
Groundable Acetal 10 to 180 F (Ć12 to 82 C). . . . . . .
Hytrel Ć20 to 150 F (Ć29 to 66 C). . . . . . . . . . . . . . .
Neoprene 0 to 200 F (Ć18 to 93 C). . . . . . . . . . . . .
Nitrile 10 to 180 F (Ć12 to 82 C). . . . . . . . . . . . . . . .
Polypropylene 35 to 150 F (2 to 66 C). . . . . . . . . .
Polyurethane 10 to 150 F (Ć12 to 66 C). . . . . . . . . . .
P.V.D.F. (Kynar) 10 to 200 F (Ć12 to 93 C). . . . . . . . .
Santoprene Ć40 to 225 F (Ć40 to 107 C). . . . . . . . . .
T.F.E. (Teflon)40 to 225 F (4 to 107 C). . . . . . . . .
Viton Ć40 to 350 F (Ć40 to 177 C). . . . . . . . . . . . . . .
Groundable 666056ĆX and 66605HĆX models only. . . . . . . . . . .
Dimensional Data see page 8. . . . . . . . . . . . . . . .
Noise Level @ 70 p.s.i., 60 c.p.m. 71.1 db(A). . . . .
* The pump sound pressure levels published here have been updated to an Equivalent
Continuous Sound Level (L
Aeq
) to meet the intent of ANSI S1.13Ć1971, CAGIĆPNEUĆ
ROP S5.1 using four microphone locations.
NOTICE: All possible options are shown in the chart however certain comĆ
binations may not be recommended, consult a representative or the facĆ
tory if you have questions concerning availability.
666053ĆXXX
666056ĆXXX
666057ĆXXX
66605JĆXXX
66605HĆXXX
66605KĆXXX
Figure 1
MODEL DESCRIPTION CHART
66605 X Ć X X X
66605X Ć X X X
637140 Ć X X
DiaphragmBall
FLUID SECTION SERVICE KIT SELECTION
EXAMPLE: MODEL # 666053Ć321
Fluid Section Service Kit # 637140Ć21
SEAT MATERIAL
0 Ć (Duck Bill) 4 Ć P.V.D.F. (Kynar)
2 Ć Stainless Steel 6 Ć Acetal
3 Ć Polypropylene
BALL MATERIAL
( * ) Duckbill models
1 Ć Neoprene 8 Ć Polyurethane
2 Ć Nitrile A Ć Stainless Steel
3 Ć Viton C Ć Neoprene (*)
4 Ć T.F.E. (Teflon) D Ć Nitrile (*)
5 Ć E.P.R. E Ć Santoprene
DIAPHRAGM MATERIAL
1 Ć Neoprene 5 Ć E.P.R.
2 Ć Nitrile 8 Ć Polyurethane
3 Ć Viton 9 Ć Hytrel
4 Ć T.F.E. (Teflon) / Santoprene B Ć Santoprene
FLUID CAPS & MANIFOLD MATERIAL
3 Ć Piece Manifold Single Piece Manifold
3 Ć Polypropylene J Ć Polypropylene
6 Ć Groundable Acetal H Ć Groundable Acetal
7 Ć Pure Kynar K Ć Pure Kynar
www.bymisa.mx, Email ventas@bymisa.mx
To Next Page
Need help?
General
