Ashley AW1120E-P User Manual

AW1120E-P • AW1120E-BP
AW1120E-L • AW1120E-BL
853573H-1805K
R
Report Number: F19-473
Tested Per EPA Methods ALT-125, ASTM
E2515, ASTM E3053 and CSA B415
Certied to UL 1482-2011 (R2015) and
ULC-S627-00-REV1
Mobile home approved USA & Canada
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
© 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380 Ph. 800-750-2723
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
Owner’s Instruction and Operation Manual
U.S. Environmental Protection Agency
Certied to comply with 2020 particulate
emissions standards.
SAFETY NOTICE: If this heater is not properly installed, a house re may result.
For your safety, follow the installation instructions. Never use make-shift
compromises during the installation of this heater. Contact local building or
re ofcials about permits, restrictions and installation requirements in your
area. NEVER OPERATE THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury,
or even death. Improper Installation Will Void Your Warranty!
Save These Instructions In A Safe Place For Future Reference.
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to www.P65warnings.ca.gov
Model Numbers:

Ashley AW1120E-P Specifications

General

Type	Wood Stove
Efficiency	75%
Material	Steel
Log Size	18 inches
Fuel Type	Wood
Log Length	18 inches

Summary

Introduction

Cautions

Lists important safety warnings for operating the stove.

Assembly Instructions

Tools and Materials

Lists necessary tools and materials for assembly.

Blower Assembly

Instructions for assembling the blower unit.

Flue Collar Assembly

Instructions for mounting the flue collar.

Installation

Safety Notice

Critical safety information regarding proper installation to prevent fires.

Positioning the Stove

Guidelines for optimal placement of the wood stove for heat distribution.

Floor Protector

Requirements for non-combustible floor protection under the stove.

Clearances to Combustibles

Essential clearance requirements to prevent fires with nearby materials.

Factory Built Chimney

Requirements and considerations for installing factory-built chimneys.

Masonry Chimney

Guidelines for ensuring masonry chimneys meet safety standards.

Combustible Wall Chimney Connector Pass-Throughs

Methods for safely passing chimney connectors through combustible walls.

Operation Instructions

Never Operate This Product While Unattended

Critical warning against leaving the appliance unsupervised during operation.

General Safety Precautions

Essential safety measures for operating the wood stove safely, including fire hazards.

Wood Stove Utilization

Guidance on the proper type of fuel and its characteristics for efficient burning.

Fueling and Testing

Instructions for loading fuel, initial burns, and testing wood dryness.

Blower Operation

Instructions for operating and maintaining the stove's variable-speed blower.

Chimney Maintenance

Creosote Management

Covers creosote formation, prevention, removal, and related warnings.

Ash Removal & Disposal

Procedures for safely removing and disposing of ashes from the stove.

Glass & Gasket Care

Instructions for cleaning and maintaining the stove's glass door and door gasket.

Repair Parts

Service Record

Notes