33..44 SSeerrvviicce e / / RReegguullaar r mmaaiinntteennaanncce e / / DDaaiilly y sseerrvviiccee
ATLET SERVICE MANUAL A-ERGOATLET SERVICE MANUAL A-ERGO
Daily serviceDaily service
This section provides informatiThis section provides information on what the truck owner should take into consideration on what the truck owner should take into consideration.on.
The truck driver is obliged to do the following (before each shift)The truck driver is obliged to do the following (before each shift)
Important!Important!
NOTE! Naked flames or smoking are prohibited when checking the specific acidNOTE! Naked flames or smoking are prohibited when checking the specific acid
weight and the acid level.weight and the acid level.
NOTE! Ergonomic loading procedures should be taken iNOTE! Ergonomic loading procedures should be taken into consideration whennto consideration when
replacing the battery or checking the battery to replacing the battery or checking the battery to avoid injuries.avoid injuries.
1.1. The baThe batterttery acid y acid levelevel shol should buld be chee checked cked every every dayday. See . See sepaseparate rate servserviceice
instruction. Note that the acid level rises slightly during charging.instruction. Note that the acid level rises slightly during charging.
2.2. Check Check that that the bathe battery ttery cabcables, cles, conneonnectionctions and s and pluplugs are gs are correcorrectly ctly connconnected ected andand
undamaged.undamaged.
3.3. CheCheck thck that the bat the battattery is pery is proroperperly loly lockcked in ied in its cots compampartmertment.nt.
4.4. CheCheck ck whwhethether er the the trutruck ck hahas ls leaeaked ked oiloil..
5.5. CheCheck tck the the traransnspoport art and snd safafetety siy signgnalal..
6.6. CheCheck thck the brae brakinking capg capacacity oity of the maf the main bin brakrake and pe and parkarking bing brakrake.e.
7.7. CheCheck tck that hat the the whewheels els havhave no e no exexterternal nal dadamagmage.e.
8.8. On truOn trucks eqcks equippeuipped with d with a truca truck comk computeputer, r, check check that ththat the tese test routt routine iine is folls followedowed
and that no error and that no error messages are shown on the displaymessages are shown on the display..
9.9. ChChececk thk the bae batttterery iny indidicacatotorr..
Important!Important!
NOTE! Faults detected during daily maintenance are rNOTE! Faults detected during daily maintenance are reported to the foreman. Seeeported to the foreman. See
driver instructions.driver instructions.
The truck driver is obliged to do the following (after each shift)The truck driver is obliged to do the following (after each shift)
Battery chargingBattery charging
..
Battery service must only be carried out by specially trained personnel. This training isBattery service must only be carried out by specially trained personnel. This training is
provided during the truck driver course. The battery may, however, be charged by otherprovided during the truck driver course. The battery may, however, be charged by other
personnel on the assumption that the battery plug is used to connect the battery to thepersonnel on the assumption that the battery plug is used to connect the battery to the
charging unit. The battery is charged according to the charging unit. The battery is charged according to the recommendations of the batteryrecommendations of the battery
manufacturermanufacturer. Only fully . Only fully automatic charging units should be used. The automatic charging units should be used. The battery chargingbattery charging
should be checked by measuring the acid weight should be checked by measuring the acid weight in the cells if in the cells if an unregulated chargeran unregulated charger
isis ususeded..
To Next Page
Loading...