SSeervrviice ce / R/ Reegguulalar mr maaiinntetennaancnce / e / WeWeeeklkly sy seerrvivice ce (3(30 o0 oppeerraatitinng hg hoouurrs)s) 33.5.5
ATLET SERVICE MANUAL A-ERGOATLET SERVICE MANUAL A-ERGO
Important!Important!
NOTE! The acid weight should also be checked when an automatic charger is used.NOTE! The acid weight should also be checked when an automatic charger is used.
For other details concerning the battery and fully automatic chargers, sFor other details concerning the battery and fully automatic chargers, see theee the
separate service instrseparate service instructions for the battery and charger.uctions for the battery and charger.
Weekly service (30 operating hours)Weekly service (30 operating hours)
Responsibility: Truck driverResponsibility: Truck driver
1.1. The bThe battatterery is cly is cleaeaned ened extexternarnally wlly with waith warm warm water ater and rnd ragags.s.
2.2. Check Check the the oil loil level evel in thin the hyde hydraulic raulic systesystem by m by pushpushing oing out aut all the ll the hydrahydrauliculic
cylinders to their end positions. After this check that cylinders to their end positions. After this check that the fork carriage goes all thethe fork carriage goes all the
way up to way up to maximum lifting height without maximum lifting height without the pump sucking air.the pump sucking air.
3.3. Check Check that that the wthe wheels heels have have not not sepaseparated rated – tr– tread/head/hub ub and and treadtread/cor/cord.d.
4.4. Check Check the acthe acid weiid weight. Wght. When then the ache acid weiid weight is ght is checkchecked the ed the value value for a for a fully cfully charghargeded
battery should be 1.25–1.28 (25°C). The acid weight must not be lbattery should be 1.25–1.28 (25°C). The acid weight must not be less than 1.16ess than 1.16
(25°C), i.e. have at least 20% capacity left if the battery is to maintain its service life.(25°C), i.e. have at least 20% capacity left if the battery is to maintain its service life.
5.5. The trucThe truck shouk should be cld be cleanleaned exteed externallyrnally. V. Vacuuacuum clean am clean and wipnd wipe with a de with a damp clamp clothoth
in the driver compartment. Observe caution when using water jets. Electric panelsin the driver compartment. Observe caution when using water jets. Electric panels
and circuit cards should always be and circuit cards should always be protected from splashing water when washing.protected from splashing water when washing.
To Next Page
Loading...