8-7 Periodic Maintenance and Adjustment
ITEM
MAINTENANCE INTERVAL
(WHICHEVER COMES FIRST)
REMARKS
Hours Frequency Miles (KM)
Valve clearance 100 H 12M 1000 (1600) Inspect; adjust
Extreme Maintenance Check (cut the Routine Maintenance Schedule in half)
*Service Note: Under extreme use, change gear case fluid every 25 hours. "Extreme Use" is defined as
constant 4WD
operation on hilly or mountainous terrain, or if 4WD is the primary mode of operation.
LUBRICATION RECOMMENDATIONS
Check and lubricate all components at the intervals outlined in the Periodic Maintenance
Chart above, or more often under severe use, such as wet or dusty conditions. Items not
listed in the chart should be lubricated at the general lubrication interval.
ITEM LUBE METHOD
Engine Oil See Viscosity Chart (10-2) Add to proper level on dipstick.
Brake Fluid DOT 3 or 4 Brake Fluid Maintain level between fill lines.
Rear Differential SAE 80w90
Fill to bottom of fill plug or
0.455L or 14 oz.)
Front Differential Dextron 3 ATF
Fill to bottom of fill plug or
(volume of oil)
Drive Shaft U-Joint Grease Locate fittings and grease.
To Next Page
Loading...