AXIS OFF-ROAD 500cc - Page 153

8-55 Periodic Maintenance and Adjustment
Table 3: Solution of Common Problems in Electrical System
S/N Problems Solutions
1 Lights do not work.
1. Check if the headlight switch functions properly.
2. Check if the wires are broken.
3. Check if the lamps or bulbs are broken.
2
Vehicle cannot go into 4
wheel drive mode.
1. Check if the control switch on meter board works well.
2. Check if the differential lock control magneto plug in rear
brid
g
e reduction
g
ear box is broken.
3. Check if the wire is broken.
3
Rear differential will not
work.
1. Check if the control switch on meter board works well.
2. Check if the differential lock control magneto plug in rear
brid
g
e reduction
g
ear box is broken.
3. Check if the wire is broken.
4
Meter display is not
normal.
1. Check if the sensor is broken.
2. Check if the meter is broken.
3. Check if the surface of speed sensor is contaminated with
iron dust.
5
Start switch on meter
board will not work.
1. Check if the switch is broken.
2. Check if the wire is broken.
3. Check if the ECU in electrical injection system is broken.