Baotian Classic - Scooter Panels

100 pages

Save Page as PDF

To Previous Page

C. Scooter Panels

Main Page

Driving Belt Device & the Starting Lever1
Detaching the Left Crankcase Cover1
Removing the Starting Pivot1
Checking the Starting Pivot2
Installing the Starting Assembly2
Assembling the Left Crankcase Cover3
Checking/Replacing the Driving Belt4
Assembling the Driving Belt5
The Driving Pulley-Dismounting5
Taking the Driving Pulley Apart5
Checking the Driving Pulley6
Overrunning Clutch Removal/Checking/Assembling7
Driving Pulley7
The Overrunning Clutch (Starter Pinion) Removal7
The Clutch/Transmission Pulley Removing the Clutch/Transmission Pulley8
Disassembling the Clutch/Transmission Pulley8
Checking the Clutch Transmission Pulley9
Replacing the Transmission Pulley and the Bearing10
The Clutch/Transmission Pulley Assembly11
Assembling the Clutch Housing12
The Final Transmission Assembly13
The Final Transmission Assembly - General Information/Troubleshooting14
Dismantling the Final Transmission Assembly15
Detach the Final Transmission Gearbox Cover15
Replacing Bearing (on the Side of the Transmission Gearbox Cover)16
Replacing the Bearing (on the Side of the Side of the Crankcase)17
Assembling the Final Gear Set17
The Crankcase and the Crankshaft19
The Crankcase and the Crankshaft - Tech Criteria/Troubleshooting20
Dismantling the Crankcase21
The Crankshaft22
Assembling the Crankcase23
The Front Wheel, Front Brake, Front Buffer and the Front Fork27
The Front Wheel, Front Brake, Front Buffer and the Front Fork - Tech Criterion/Torque28
The Front Wheel, Front Brake, Front Buffer and the Front Fork - Troubleshooting29
Removing/Assembling the Steering Handlebars30
Front Wheel Removal/Checking31
Dismantling of Wheel32
Assembly of Wheel33
Assembling the Front Wheel34
Dismounting the Front Shock35
Dismantling the Front Shock36
Assembling Sequence37
Front Fork Removal38
Replacing the Ball Cone Race/Upper Race38
Assembling the Upper Race39
Checking the Brake Lining40
Dismantling/Assembling the Front Brake40
The Rear Wheel, the Rear Brake & Rear Shock43
The Rear Wheel, the Rear Brake & Rear Shock - Tech Criterion/Torque/Troubleshooting44
Detaching/Checking/Assembling the Rear Wheel45
Checking the Brake Lining (Rear)46
Dismantling/Assembling the Rear Brake46
Dismountling the Rear Shock47
Assembling the Rear Shock48
The Battery and the Charging System50
The Battery and the Charging System - Important Points51
The Battery and the Charging System - Tech Criteria/Torque/Troubleshooting52
Detaching the Battery53
Checking the Charging Condition (Open Circuit Volt)53
Charging53
Testing Short Circuit55
The Rectifying Voltage Stabilizer56
Checking the Rectifying Voltage Regulator56
The Magneto Charging Coil Checking57
The Magneto Lighting Coil Checking57
Checking the Resistor57
Dismounting the Magneto57
Assembling the Magneto59
Ignition System - Diagrams63
Ignition System - General Information/Reference Standard64
Ignition System - Troubleshooting65
CDI Inspection66
Ignition Coil Removal Steps67
Magneto Pickup Coil Inspection68
Charging Coil Inspection68
Spark Advance Angle Inspection68
Starter System69
Starter System - Installatin Reference Standard/Fastener Torque Specification/Troubleshooting70
Starter Motor Removal71
Starter Disassembly/Inspection71
Starter Relay Inspection73
To Inspect Starter Relay74
Starter Motor Installation74
Meters, Switches and Lighting System - Maintenance/Troubleshooting77
Fuel Sensor Removal/Installation/Testing78
Fuel Gauge Inspection78
Handlebar Switches Inspection79
Lights/Starter/Dimmer/Turn Light/Engine Stop Switches79
Hom Switch80
Replacing the Horn Switch80
Main Switch Inspection/Replacement80
Brake Light Switch Inspection81
Horn Inspection81
To Replace the Horn Switch81
Speedometer Removal and Reinstallation81
Headlight Removal and Installation82
Bulb Replacement and Installation82
Taillight, Brake Light, Rear Position82
Underside of Cover Diagram82
Electric Scooter Assembly83
Electric Scooter Assembly - Important Points/Torque84
Electric Scooter Assembly - Scheduled Maintenance85
Electric Scooter Assembly - Specifications/Troubleshooting86
Dismantling and Removing Rear Wheel Assembly87
When Dismantling/Assembling the Rear Brake88
Electric Motor Removal90
Motor Disassembly92
Motor Inspection94
Battery Access and Power95
Battery Access and Removal97
Recharging Batteries98
Retro Model Scooter Panels99
Scooter Panels100

Related product manuals

Baotian Classic - Scooter Panels

Table of Contents

Related product manuals