Bauer Compressors P41 - 2.1.7.1 Calculating the Maximum Cartridge Operating Hours; CHAPTER 3: SINGLE CHAMBER PURIFICATION SYSTEMS; 3.2 P0 Purification System; 3.3 P31 Purification System

MNL-0096
April 17, 2013 Page iv
5.2.2.2 Chamber........................................................................................................................................................................62
5.2.2.3 Cartridge Leaks after Installation .................................................................................................................................63
5.2.3 Replacement Parts List ....................................................................................................................................................64
5.3 P14 PURIFICATION SYSTEM.......................................................................................................................................72
5.3.1 Major Components...........................................................................................................................................................72
5.3.1.1 Oil and Water Separator ...............................................................................................................................................73
5.3.1.2 Condensate Drain Valve...............................................................................................................................................73
5.3.1.3 Check Valves................................................................................................................................................................73
5.3.1.4 Dryer Cartridge.............................................................................................................................................................73
5.3.1.5 Bleed Valve ..................................................................................................................................................................73
5.3.1.6 Pressure Maintaining Valve..........................................................................................................................................73
5.3.1.7 Safety Valve..................................................................................................................................................................73
5.3.1.8 Securus
®
Electronic Moisture Monitor System............................................................................................................73
5.3.1.9 Securus
®
Cartridge........................................................................................................................................................73
5.3.1.10 Securus
®
Indicator ........................................................................................................................................................73
5.3.2 Maintenance .....................................................................................................................................................................74
5.3.2.1 Oil and Water Separator ...............................................................................................................................................74
5.3.2.2 Chamber........................................................................................................................................................................75
5.3.2.3 Cartridge Leaks after Installation .................................................................................................................................76
5.3.3 Replacement Parts List ....................................................................................................................................................77
CHAPTER 6: - - - - - - - - - - - - - - - - - - - - - - - - APPENDIX
6.1 SAFETY..............................................................................................................................................................................86
6.1.1 General Safety Precautions ..............................................................................................................................................86
6.1.2 Safety Warning Labels.....................................................................................................................................................88
6.2 UNPACKING, HANDLING AND INSTALLATION ...................................................................................................89
6.2.1 Unpacking and Handling..................................................................................................................................................89
6.2.2 Installation of the Unit......................................................................................................................................................89
6.2.2.1 General..........................................................................................................................................................................89
6.2.2.2 Electrical Installation....................................................................................................................................................89
6.3 LONG TERM STORAGE.................................................................................................................................................90
6.3.1 General .............................................................................................................................................................................90
6.3.2 Preparations......................................................................................................................................................................90
6.3.2.1 Units Equipped with a Filter System............................................................................................................................90
6.3.3 Preserving the Compressor...............................................................................................................................................90
6.3.4 Preventive Maintenance During Storage..........................................................................................................................91
6.3.5 Lubrication Oils for Preservation.....................................................................................................................................91
6.3.6 Reactivating the Compressor Unit ...................................................................................................................................91
6.4 REFERENCE DATA.........................................................................................................................................................93
6.4.1 Tightening Torque Values................................................................................................................................................93
6.4.2 Torque Sequence Diagrams .............................................................................................................................................93
6.4.3 Conversion Formulas .......................................................................................................................................................93
6.4.4 Approved Lubricants Chart..............................................................................................................................................94
6.4.5 Glossary of Abbreviations and Acronyms .......................................................................................................................94
6.5 ADDITIONAL DOCUMENTS ........................................................................................................................................95
6.5.1 Diagrams and Drawings...................................................................................................................................................95
6.5.2 Other Documents..............................................................................................................................................................95