Bauer 1761C-B - Kickback and Related Warnings

Page 5;&(%$*4.8"4,7%I'*#$"&8#>%/7*,#*%4,77%JKLLLKLMMKNOPO1Item 56401
HB;6QRST6=BQUSVWBUVQ6VBVG6 H6Q?T
11. V*Z*(%7,D%$.*%/&)*(%$&&7%9&)8%'8$"7%$.*%
,44*##&(D%.,#%4&5*%$&%,%4&5/7*$*%#$&/1%
7KHVSLQQLQJDFFHVVRU\PD\JUDEWKHVXUIDFH
DQGSXOOWKHSRZHUWRRORXWRI\RXUFRQWURO
12. Y&%8&$%('8%$.*%/&)*(%$&&7%)."7*%4,((D"83%
"$%,$%D&'(%#"9*1%Accidental contact with the
VSLQQLQJDFFHVVRU\FRXOGVQDJ\RXUFORWKLQJ
SXOOLQJWKHDFFHVVRU\LQWR\RXUERG\
13. =*3'7,(7D%47*,8%$.*%/&)*(%$&&7_#%,"(%Z*8$#1%
The motor’s fan will draw the dust inside
WKHKRXVLQJDQGH[FHVVLYHDFFXPXODWLRQRI
SRZGHUHGPHWDOPD\FDXVHHOHFWULFDOKD]DUGV
14. Y&%8&$%&/*(,$*%$.*%/&)*(%$&&7%8*,(%27,55,+7*%
5,$*(",7#1%6SDUNVFRXOGLJQLWHWKHVHPDWHULDOV
15. Y&%8&$%'#*%,44*##&("*#%$.,$%(*I'"(*%7"I'"9%
4&&7,8$#1%Using water or other liquid coolants
may result in electrocution or shock.
16. Maintain labels and nameplates on the tool.
These carry important safety information.
If unreadable or missing, contact
Harbor Freight Tools for a replacement.
17. Avoid unintentional starting.
Prepare to begin work before turning on the tool.
18. Do not depress the spindle lock when
starting or during operation.
19. Do not leave the tool unattended when the
Battery Pack is connected. Turn off the tool,
and remove the Battery Pack before leaving.
20. Use clamps (not included) or other practical
ways to secure and support the workpiece to
a stable platform. Holding the work by hand
or against your body is unstable and may
lead to loss of control and personal injury.
21. The battery charger gets hot during
use. The charger’s heat can build up to
unsafe levels and create a fire hazard if
it does not receive adequate ventilation,
due to an electrical fault, or if it is used in a hot
environment.
Do not place the charger on a flammable surface.
Do not obstruct any vents on the charger.
6#/*4",77D%,Z&"9%/7,4"83%$.*%4.,(3*(%&8%4,(/*$#%
,89%('3#`%$.*D%,(*%8&$%&87D%27,55,+7*>%+'$%$.*D%
,7#&%&+#$('4$%Z*8$#%'89*(%$.*%4.,(3*(1
22. This product is not a toy.
Keep it out of reach of children.
23. People with pacemakers should consult their
physician(s) before use. Electromagnetic fields in
close proximity to heart pacemaker could cause
pacemaker interference or pacemaker failure.
In addition, people with pacemakers should:
• Avoid operating alone.
• Do not use with power switch locked on.
• Properly maintain and inspect
to avoid electrical shock.
• Properly ground power cord. Ground Fault Circuit
Interrupter (GFCI) should also be implemented
– it prevents sustained electrical shock.
24. The warnings, precautions, and instructions
discussed in this instruction manual cannot
cover all possible conditions and situations
that may occur. It must be understood by the
operator that common sense and caution are
factors which cannot be built into this product,
but must be supplied by the operator.
\"4[+,4[%,89%=*7,$*9%F,(8"83#
Kickback is a sudden reaction to a pinched or
snagged rotating wheel, backing pad, brush
or any other accessory. Pinching or snagging
causes rapid stalling of the rotating accessory
which in turn causes the uncontrolled power
tool to be forced in the direction opposite of the
accessory’s rotation at the point of the binding.
For example, if an abrasive wheel is snagged or
pinched by the workpiece, the edge of the wheel that
is entering into the pinch point can dig into the surface
of the material causing the wheel to climb out or kick
out. The wheel may either jump toward or away from
the operator, depending on direction of the wheel’s
movement at the point of pinching. Abrasive wheels
may also break under these conditions.
Kickback is the result of power tool misuse and/or
incorrect operating procedures or conditions and can be
avoided by taking proper precautions as given below.
1. W,"8$,"8%,%2"(5%3("/%&8%$.*%/&)*(%$&&7%,89%
/&#"$"&8%D&'(%+&9D%,89%,(5%$&%,77&)%D&'%$&%
(*#"#$%["4[+,4[%2&(4*#1%B7),D#%'#*%,']"7",(D%
.,897*>%"2%/(&Z"9*9>%2&(%5,]"5'5%4&8$(&7%&Z*(%
["4[+,4[%&(%$&(I'*%(*,4$"&8%9'("83%#$,($K'/1
7KHRSHUDWRUFDQFRQWUROWRUTXHUHDFWLRQVRU
NLFNEDFNIRUFHVLISURSHUSUHFDXWLRQVDUHWDNHQ
2. V*Z*(%/7,4*%D&'(%.,89%8*,(%$.*%
(&$,$"83%,44*##&(D1%Accessory may
kickback over your hand.
3. Y&%8&$%/&#"$"&8%D&'(%+&9D%"8%$.*%,(*,%).*(*%
/&)*(%$&&7%)"77%5&Z*%"2%["4[+,4[%&44'(#1%%
.LFNEDFNZLOOSURSHOWKHWRROLQGLUHFWLRQRSSRVLWH
WRWKHZKHHO¶VPRYHPHQWDWWKHSRLQWRIVQDJJLQJ