17
V. Cleaning Instructions
A. INITIAL CLEANING:
Prior to operating your new Char-Grill, perform the Cast Grates “Burn-OFF”, when the Char-
Grill is first heated, it will smoke until oil used in manufacturing, preservation and dust from
storage and shipping are burned off. Wash with soap and water before use.
B. DAILY CLEANING:
1. Remove the grease pan and empty it.
2. Cast Grates “Burn-OFF”. The grease buildup on the grates should be cleaned daily (or more often
as needed). Do not cover the top of the grates during “Burn-OFF” operation. Restricting the air
flow by covering the grates may cause them to warp. It will also cause damage to the valves,
knobs, and front panel.
Caution: When handling grates or radiants, always use heat insulated gloves to prevent burns.
Warning: Do not cover the top of the grates during a burn off operation. Restricting the airflow
by covering the grates may cause them to warp. It will also cause damage to the valves, the
knobs and the front panel.
3. Place grates on Char-Grill, with grid bars horizontal, facing down.
4. Wash the Char-Grill with soap and water after it runs cold
5. Turn off the Char-Grill and allow it to cool for 20 Minutes or more.
6. Clean top and bottom surfaces of the grates with a soft wire brush to remove fats and
caramelized grease.
7. Clean channels on grates with a scraper.
8. Remove radiants from Char-Grill. Clean the top surface of radiants with soft wire brush to remove
any food debris or caramelized grease deposits.
9. For units with lava rocks, remove the lava rocks and wash them with mild detergent and with
warm water.
10. Brush the rocks with soft bristled brush to remove any food debris or caramelized grease that
stuck on the rocks. Check the rocks for cracks and damage, and replace with new ones if
necessary.
11. Then return the cast grates properly to the equipment. See also page 11 for correct installation
of cast grates.
NOTE:
a. If the Char-Grill usage is very high, we recommend that a more thorough cleaning is carried
out on a more frequent basis. Refer to WEEKLY CLEANING.
b. DO NOT use harsh abrasive detergents, strong solvents or caustic detergents as they will
damage the grate and burners.
To Next Page
Loading...
