OWNER’S INSTRUCTION & SAFETY MANUAL
Contents
Section Page
Introduction 2
I. Hardware Bag Contents and Tool List 3
II. Mounting the Reflectors 3
III. Installing the Quick-Release Levers 4
IV. Attaching the Wheels 4
V. Unfolding and Folding Your Burley d’Lite 6
VI. Using the Seat Harness 8
VII. Reclining Seat, Helmet Pocket, Child Seat Divider 10
VIII. Completing Assembly 11
IX. Hitching the Burley d’Lite to Your Bicycle 12
X. Trailer Maintenance and Care 14
XI. Safety Guidelines 15
XII. Safety Checklists 21
XIII. Parts List and Drawing 22-23
Warranty 24
Burley d’Lite
TM
About Burley Design Cooperative
Burley has been supplying products to the bicycle industry since 1975. Burley
products are designed and manufactured at our Eugene, Oregon shop. As
worker-owners of our cooperatively owned business, we bring an uncommon
degree of personal pride and attention to our work. Use our products with
confidence and satisfaction!
Burley Trailer Limited Warranty
Burley will repair or replace any original equipment parts it
determines to be defective for the life of the trailer. The owner
of a Burley trailer must present the trailer for repair at an
authorized Burley dealer, together with an original sales
receipt or similar proof of purchase. This warranty applies only
to the original owner and is nontransferable. Burley cannot be
responsible for failure due to improper assembly, modification
of parts or instructions, neglect, abuse, accident, and/or
normal wear. The warranty does not cover any trailers used for
rental, competition, or commercial use.
Burley neither assumes nor authorizes any person to
assume any other liability in connection with Burley
trailers, and there are no oral agreements or warranties
collateral to or affecting this agreement.
This warranty gives you specific legal rights and you may also
have other rights which vary from state to state.
Burley Design Cooperative • 4020 Stewart Rd. • Eugene, OR 97402 USA
(541) 687-1644 • Fax (541) 687-0436
Copyright © 2001 by Burley Design Cooperative • www.burley.com
“Burley” is a registered trademark of Burley Design Cooperative
and “d’Lite” is a trademark of Burley Design Cooperative
Printed on unbleached 100% recycled paper rev 10/01
To Next Page
Need help?
General
