Carrier 38EH030 User Manual

HEATING & COOLING
38E,Q
Condensing Units and Heat Pumps
Service Manual
38EH,EN,ES,QH,QN,QS
TABLE OF CONTENTS
Page
INTRODUCTION. 1, 2
Models and SEER Ranges. 1
Factory-Installed Options. 2
SAFETY CONSIDERATIONS . . . . .. 3
SERVICE. 3
Cabinet. 3
• REMOVING LOUVERED CASING
• REMOVING FAN ORIFICE
• ELECTRICAL BOX ACCESS
Electrical. 5 - 1 1
• CONTACTORS
• CAPACITORS
• TIME GUARD II
• CRANKCASE HEATER
• PRESSURE SWITCHES
• DEFROST THERMOSTATS ,
• PRINTED-CIRCUIT CONTROL BOARD
• FAN MOTORS
• SERVICE SENTRY CONTROL BOARD
• OUTDOOR THERMOSTATS
Page
Compressor.12-15
• MECHANICAL FAILURES
• ELECTRICAL FAILURES
• SYSTEM CLEAN-UP AFTER BURN-OUT
• COMPRESSOR REMOVAL AND
REPLACEMENT
Refrigeration System . 1 5 - 20
• REFRIGERATION CYCLE
• LEAK DETECTING
• SERVICE VALVES
• CARRIER COMPATIBLE FITTING
• ACCURATER ™ (Bypass Type) COMPONENTS
• REVERSING VALVE
• COIL REMOVAL
• COIL CLEANING
• LIQUID LINE STRAINER
• ACCUMULATOR
• SYSTEM CHARGING (for all approved
combinations)
INTRODUCTION
This Service Manual enables a service technician to similar, however, there are distinct differences. Tables 1
service and repair a family of similar condensing units and 2 help to differentiate these differences,
and heat pumps. Outwardly, many models appear
Models and SEER Ranges
Table 1 — Condensing Units Table 2 — Heat Pumps
MODEL
DIAMETERS SEER*
MODEL
DIAMETERS
SEER* C:O.P.f
(in.)
(Nominal)
(in.)
(Nominal)
(Minimum)
38EH015
22
9.0
38QH015
22
•9.0
2.85
38EH018 22
9.0
38QH018
22
9.0
2.85
38 EH 024
22
9.0
38QH024 30
9.0
2.85
38 EH 030 30
9.0
38QH030 30
9.0 2.85
38 EH 036 30 9.0
38QH036
30
9.0
2.85
38 EH 042 30 9.0
38QH042 30
9.0
2.85
38 EH 048 30 9.0
38QH048
30
9.0
2.85
38 EH 060
30
9.0
38QH060 39
9.0 2.85
38EN015
17
8.0
38QN015
17
8.0
2.55
38EN018
17
8.0
38QN018
17
8.0
2.55
38EN024
17
8.0
38QN024 22
8.0
2.55
38EN030 22
8.0
38QN030
22
8.0 2.55
38EN036
22
8.0
38QN036 30
8.0
2.55
38EN042 30 8.0
38QN042
30
8.0 .
2.55
38EN048 ' 30 8.0
38QN048
30
8.0
2.55
38EN060
30 8.0
38QN060
30
8.0
2.55
38ES018
30 ■
10.0
38QS018
30
10.0
2.85
38ES024
30 10.0
38QS024
30
10.0
2.85
38ES030
30
10.0
38QS030 30
10.0
2.85
38ES036
30
10.0
38QS036
30
10.0
2.85
38ES042
30
10.0
38QS042
30
10.0
2.85
38ES048
30
10.0
38QS048
30
10.0
2.85
38ES060 39
10.0
38QS060
39
10.0 2.85
SEER Seasonal Energy Efficiency Ratio. The higher the number, the fC.O.P. — Coefficient of Performance (heating), determined by dividing
less electrical power required to reach a given capacity. SEER Btu output by power input required to produce this Btu output,
is derived by dividing output energy by input energy.
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
Book 1 1 |1 |4 |4 PC101 Catalog No. 563-857 Printed in U.S.A. Form38E,Q-1SM Pg 1 11-85 Replaces: New
Tab 3a|5a|2a|5a For replacement items use Carrier Specified Paris.

Carrier 38EH030 Specifications

General

Refrigerant	R-410A
Compressor Type	Scroll
Phase	1
Cooling Capacity	30, 000 BTU
Heating Capacity	30, 000 BTU
Voltage	208/230
Voltage (V/Ph/Hz)	208/230V/1/60Hz

Summary

Safety and General Service Guidelines

Safety Considerations

Crucial safety precautions for technicians working on HVAC equipment.

Electrical Component Diagnostics

Contactor Function and Testing

Explains contactor operation and troubleshooting methods.

Capacitor Testing and Types

Covers capacitor roles, safety, and testing procedures.

PTC Devices and Start Assist

Time Guard II Operation

Pressure Switch Diagnostics

Covers low and high-pressure switches and their testing.

Defrost Thermostat Function

Explains defrost thermostat operation and testing procedures.

Printed-Circuit Control Board

Compressor Mechanical and Electrical Failures

Mechanical Compressor Failures

Discusses common mechanical issues causing compressor malfunction.

Electrical Compressor Failures

Outlines electrical problems affecting compressor operation and testing.

Single-Phase Motor Testing

Procedures for testing single-phase motor windings and connections.

Compressor Open Circuit Diagnosis

Compressor Ground Circuit Diagnosis

Compressor Short Circuit Diagnosis

System Maintenance and Component Service

System Clean-Up After Burn-Out

Procedures for cleaning the system after a compressor motor burn-out.

Compressor Removal and Replacement

Steps for safely removing and installing a replacement compressor.

Refrigeration Cycle Explanation

Refrigerant Leak Detection

Reversing Valve Functionality

System Charging Procedures

Guidance on proper system charging procedures for optimal performance.