Home
Carrier
Heat Pump
38MARBQ30AA3
Page 102
Carrier 38MARBQ30AA3 - Page 102
116 pages
Manual
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
102
Sp
ec
ifi
catio
ns
su
bj
ect
to
cha
ng
e w
it
hou
t not
ic
e.
SG-38M
ARB
-01
Procedur
e
Illustration
3)
Pull out the connectors.
4)
Remove the screws (9), loosen the
hooks (3) then remove the
electr
onic contr
ol board.
5)
Remove the screws (2) then remove
the electronic contr
ol box
subassembly on the partition board
assembly
.
101
103
Table of Contents
Main Page
Table of Contents
1
Introduction
1
Unit Sizes
2
Model / Serial Number Nomenclatures
2
Specifications - Heat Pump
3
Dimensions and Weights
4
Clearances for Multiple Units
7
Clearances
7
Recommended Connection Method for Power and Communication Wiring
8
Electrical Data
8
Wiring
8
Connection Diagrams
9
Wiring Diagram Size 12K (115V)
10
Wiring Diagrams
10
Fan and Motor Specifications
14
Refrigeration Cycle Diagrams
15
Refrigerant Cycle Diagrams 9K (208/230V)
16
Refrigerant Cycle Diagram 12K (208/230V)
17
Refrigerant Cycle Diagram 18K (208/230V)
18
Long Line Applications
22
General Refrigerant Line Sizing
22
Refrigerant Lines
22
System Vacuum and Charge
23
Using Vacuum Pump
23
Deep Vacuum Method
23
System Evacuation and Charging
23
Main Protection
24
Outdoor Fan Running Rules
24
Inverter Module Protection
24
Electronic Functions
24
Evaporator Temperature Protection
25
Indoor Fan Running Rules
25
Compressor Temperature Protection
25
DEFROST Mode
27
Forced DEFROSTING Mode
27
Evaporator Coil Temperature Protection
28
DRYING Mode
28
FORCED OPERATION Function
28
Enquiry Information
29
Point Check Function
29
Electrolytic Capacitors
30
Discharge Position
30
Safety
30
Troubleshooting
30
Indoor Unit Diagnostic Guides
31
Outdoor Unit Error Display
32
Sizes 12 (115V)
32
Diagnosis and Solution
32
Indoor and Outdoor Unit Communication Error (EL01)
34
Zero Crossing Detection Error Diagnosis and Solution (EH02)
36
The Indoor Fan Speed Is Operating Outside of the Normal Range (EH03)
37
DC Fan Motor (Control Chip Is in the Fan Motor)
38
The Outdoor Fan Speed Is Operating Outside of Normal Range (EC07)
39
Outdoor DC Fan Motor (DC Motor that Controls the Chip on the PCB)
40
Refrigerant Leakage Detection (EL0C)
43
Indoor Pcb/Display Board Communication Error (EH06)
44
Current Overload Protection (PC08)
45
IPM Malfunction or IGBT Over-Strong Current Protection (PC00)
46
IPM Continuity Check
47
Compressor Check
48
Over Voltage or Low Voltage Protection (PC01)
49
Inverter Compressor Drive Error (PC04)
52
Low Pressure Protection (PC03)
53
Indoor Units Mode Conflict (Match with Multi Outdoor Unit)
54
Check Procedures
56
Temperature Sensor Check
56
Resistance Value
57
Way Valve Check
59
Measure the Voltage
59
Use a Digital Tester to Measure Resistance
59
EXV Check
60
Winding Colors
60
Main Parts Check
61
Temperature Sensor Checking
61
Pressure on Service Port
62
Cooling Chart
62
Heating Chart (R410A)
63
System Pressure
64
System Pressure Table-R410A
64
Outdoor Unit Sizes 9-12K (115V) Panel Plate
65
Disassembly Instructions
65
PCB Board 3
92
Four Way Valve (for Heat Pump Models)
110
Compressor
111
Safety Caution
113
Temperature Sensor Resistance Value Table for T1, T2, T3, T4
114
Temperature Sensor Resistance Value Table for T5
115
Related product manuals
Carrier 38MARBQ36AA3
116 pages
Carrier 38MARBQ12AA1
116 pages
Carrier 38MARBQ09AA3
116 pages
Carrier 38MARBQ12AA3
116 pages
Carrier 38MARBQ18AA3
116 pages
Carrier 38MARBQ24AA3
116 pages
bryant Multi-Zone 38MARBQ09 18AA3 Series
70 pages
bryant Multi-Zone 38MARBQ24 36AA3 Series
70 pages
Carrier 38MARB
84 pages
Carrier 38MURA
8 pages
Carrier 38MBRCQ36AA3
58 pages
Carrier 38MURAQ30AA3
20 pages
To Next Page
Loading...
