Carrier 48FP - Page 3

To Next Page

To Previous Page

NETWORK

OPTIONS

REMOTE

CCN SITE

AUTODIAL

GATEWAY

NON CARRIER

HVAC

EQUIPMENT

TERMINAL

SYSTEM

MANAGER

TCU

ROOFTOP

UNIT

DAV AIR

TERMINAL

TCU

DAV AIR

TERMINAL

AIR DISTRIBUTION-DIGITAL AIR VOLUME CONTROL (DAV)

DAV FAN

POWERED

MIXING

BOX

ADDITIONAL

TERMINALS

HEATING/COOLING UNITS

BUILDING SUPERVISOR

ROOFTOP

UNIT

PIC

ROOFTOP

UNIT

PIC

ROOFTOP

UNIT

PIC

ROOFTOP

UNIT

PIC

CCN BUS

PIC

COMFORT

CONTROLLER

LEGEND

CCN —

Carrier Comfort Network

DAV —

Digital Air Volume

HVAC —

Heating, Ventilation, and Air Conditioning

PIC —

Product Integrated Controls

TCU —

Terminal Control Unit

Fig. 1 — CCN System Architecture

Main Page

Table of Contents1
Safety Considerations2
General2
- Architecture2
PIC Rooftop Information4
Digital Air Volume (DAV) Linkage4
Major Control Components4
General4
- PROCESSOR MODULE no . 1 (Standard)4
- Control Options Module4
- Dsio2)4
- Transducers4
- Components4
- Space Temperature Sensor (T-55)6
- SPACE TEMPERATURE SENSOR (T-56) (Use with CV6
- Indoor Air Quality (Co 2 ) Sensors6
- Outdoor Air Volume Control7
Controls and Functions8
Definitions8
Accessing the Control System9
- (Hsio)9
- Keypad and Display Module (Hsio)9
- Accessing Functions and Subfunctions11
Basic System Functions12
Service Group16
Schedules Group18
Economizer and Power Exhaust Group20
- Nighttime/Unoccupied Free Cooling21
Smoke Control Group24
Special Ventilation Group25
- Indoor Air Quality (Iaq)25
Dehumidification and Humidifier Group28
- Dehumidification and Reheat28
Supply Fan Duct Pressure and VAV Control Group29
- SUPPLY FAN DUCT PRESSURE CONTROL (VAV Only)29
- SUPPLY-AIR SET POINT RESET (External Signal)30
Remote Controls Group31
- SPACE TEMPERATURE OFFSET (CV Only)31
Special Systems Group31
- HEAD PRESSURE/FAN CYCLING CONTROL (Motormaster® Head Pressure Control)32
- Transducers and Suction Thermistors33
Carrier Comfort Network33
Carrier Comfort Network (CCN) Group33
Installation Information34
Control Wiring34
Smoke Control34
- Function Wiring35
Remote SASP Reset35
Remote START/OCCUPIED Control35
Timed Discrete Output41
Air Pressure Tubing41
Space Temperature Sensors41
Humidity Sensors41
Interface43
- RJ-11 Plug Wiring44
Monitor And/Or Control from Non-CCN Building Management System44
Start-Up46
Initial Check46
Set Fan Status and Check Filter Switches46
- Supply Fan Status Switch (Fs)46
- Check Filter Switch (Cfs)46
Auxiliary Switch, Power Exhaust46
Adjusting Set Points47
- Set Point Function49
Program Time Sequences52
- Schedule Function52
Start Unit53
Operating Sequences53
Head Pressure Control56
Control Loop Checkout60
Unit Operation61
Status Function61
Troubleshooting71
Checking Display Codes71
Unit Standby71
Complete Unit Stoppage71
Single Circuit Stoppage72
Restart Procedure72
Alarm and Alerts72
- Diagnostic Alarm Codes and Possible Causes72
Thermistor Troubleshooting76
Transducer Troubleshooting80
Refrigerant Pressure Transducer Replacement and Calibration80
Red Led81
- Green Led81
- Processor Module (Psio1)81
- High-Voltage Relay Modules (Dsio1 and 2)81
- Control Options Module (Psio2)83
Control Modules81
Economizer Actuator84
Variable Frequency Drive84
Quick Test86
Forcing Values87
Service87
History Function87
Service Function87
Test Function96
Unit Control Wiring96
- Appendix A - Input/Output103
- Tables 034-078103
- Appendix B - Input/Output105
- Tables 088,104105
Appendix C - CCN Points List107
Appendix D - Bacnet Points List109
- Appendix E - Carrier Default Program111
- Parameter Values111
Start-Up Checklist113

Related product manuals

Carrier 48TC 07

84 pages

Carrier CRECOMZR 004A01 Series

16 pages

Carrier 48FP - Page 3

Table of Contents

Related product manuals