Carrier AquaEdge 23XRV - Page 155

155
APPENDIX B — MAINTENANCE SUMMARY AND LOG SHEETS (cont)
23XRV Maintenance Log for Monthly, Quarterly, and Annual Checks
NOTE: Equipment failures caused by lack of adherence to the Maintenance Interval Requirements are not covered under warranty.
MONTH 123456789101112
DATE / / / / / / / / / / / / / / / / / / / / / / / /
OPERATOR
UNIT SECTION ACTION UNIT ENTRY
COMPRESSOR
Change Oil Charge yes/no Record Oil Temperature °F Send Oil Sample Out for Analysis yes/no
Perform Vibration Analysis yes/no Leak Test ppm
COOLER
Inspect and Clean Cooler Tubes yes/no Inspect Relief Valves yes/no Leak Test PPM Record Water Pressure Differential PSI Record Cooler Pressure PSI Record Entering and Leaving Water Temperature °F Inspect Water Pumps yes/no
CONDENSER
Leak Test PPM Inspect and Clean Condenser Tubes yes/no Record Water Pressure Differential (PSI) PSI Record Cooler Pressure PSI Record Entering and Leaving Water Temperature °F Inspect Water Pumps and Cooling Tower yes/no Inspect Relief Valves yes/no Replace Refrigerant Filter Drier yes/no Inspect Float Valve and Strainer yes/no
CONTROLS
General Cleaning and Tightening Connections yes/no Confirm Accuracy of Pressure Transducers yes/no Confirm Accuracy of Thermistors yes/no Perform Automated Controls Test yes/no
STARTER
General Tightening and Cleaning Connections yes/no Change VFD Refrigerant Strainer yes/no
Annually