Carter CT06 - Page 32

If touched with acid:
1. Rinse the skin
2. Use the soda or the lime to neutralize the acid.
3. Rinse eyes for 10 - l5 min and then go to doctor.
Caution:
a. Always firstly disconnect the battery clips (-) away from the ground and then lastly connect it.
b. Always keep the terminals at top to battery and the breather clean, to avoid the battery from discharging.
Check if the battery terminal is loosened or rusted. Coat the terminals with vaseline to avoid any corrosion.
Replace the battery
There is a 12V battery with one negative pole (-) grounded.
If battery cannot be charged or store any electricity, replace the battery with same model.
Replace the fuse.
If the electrical device does not work, please firstly check the fuse.
Important: please install the fuse with correct amperage, so as to prevent against burning of electrical system
due to overloading!
Others
Parts
Quantity
Interval (h)
Everyday
50
100
250
500
1000
2000
4000
Check if the bucket teeth is worn or
★
loosened.
Change the bucket
—
If needed
Replace the bucket and connect the
—
If needed, replace the bucket and connect the new one to
new one to machine.
machine.
Adjust the connecting rod of bucket
1
If needed
Take down the traveling lever
2
If needed
Check and replace the fuse
1
★
Every 3 years
Check the track defection
2
★
Check tensioner
2
★
Check the fuel injection timing
—
If needed
Check the bolts and nuts for
—

★
tightening torque
Note:
★ Maintenance interval under normal conditions
Maintenance needed at the first inspection
32