Case IH JX Series - Hydraulic Systems; Rear Mechanical Hydraulic Lift

Too l s 6........................................................................
Cross--sectional views 7.........................................................
Description & Operation 9........................................................
Hydraulic circuit 9...............................................................
Description and operation of lift phases 10.........................................
Fault diagnosis 13..............................................................
35 110.30 Hydraulic lift -- disassembly reassembly 15.........................................
35.110.40--42--46 Hydraulic lift -- bench overhaul 21.................................................
Adjusting the lift 26..............................................................
35.110.08 Linkage adjustment 32..........................................................
35.110.30 Pressure relief valve -- disassembly reassembly 34..................................
35.110.32 Pressure relief valve -- setting 34..................................................
35.110.14 Lift control valve -- disassembly assembly and overhaul on bench 36..................
35.0101.10 Lift pump 41....................................................................
Open Centre System Auxiliary Control Valves Chapter 2
Section Description Page
35 000 Main data -- Tools 1..............................................................
Auxiliary control valves -- sectional views 2..........................................
Description and operation 3.......................................................
Fault diagnosis see chapter 1.....................................................
35 204 46 Auxiliary control valves -- Assembly--Disassembly 7..................................
Spool binding test 15............................................................
Spool leakage test 16...........................................................
Adjustment of the automatic detent release pressure 17..............................
Trailer Brake Auxiliary Control Valve Chapter 3
Section Description Page
35 000 Section views 1..................................................................
Description and operation 1.......................................................
Hydraulic diagram 2..............................................................
Description and operation of valve phases 3.........................................
Trailer brake auxiliary control valve linkage adjustment 6..............................
STEERING SECTION 41
Steering Chapter 1
Section Description Page
41 000 Principal data 1..................................................................
Tightening torques 3.............................................................
Section views 4..................................................................
Hydraulic diagram 6..............................................................
Operation 7.....................................................................
Fault diagnosis 9................................................................
Too l s 10.......................................................................
41 204 30 Hydrostatic steering control valve -- Removal--Installation 11...........................
41 204 34 Hydrostatic steering control valve -- Disassembly--Assembly 14.......................
41 204 38 Hydrostatic steering control valve -- Bench testing 28................................
Hydrostatic steering oil pump -- Disassembly--Assembly 30...........................
41 216 20 Steering cylinder (two--wheel drive axle) -- Removal--Refitting 32......................
Steering cylinder (four wheel drive axle) -- Removal--Refitting 33......................
FRONT AXLE AND WHEELS SECTION 44
7