Country Hearth 2500 User Manual

Owner’s Operation and Instruction Manual
C
S
S
U
C
O
M
P
A
N
Y
U
N
I
T
E
D
S
T
A
T
E
S
S
T
O
V
E
SAFETY NOTICE:
If this heater is not properly installed, a house
re may result. For your safety, follow the in-
stallation instructions. Never use make-shift
compromises during the installation of this
heater. Contact local building or re ofcials
about permits, restrictions and installation
requirements in your area.
CAUTION!
Please read this entire manual before you
install or use your new room heater. Failure
to follow instructions may result in property
damage, bodily injury, or even death.
Improper Installation Could Void
Your Warranty!
SAFETY TESTED TO UL 1482 and ULC-S627
US ENVIRONMENTAL PROTECTION AGENCY PHASE II CERTIFIED WOODSTOVE
WASHINGTON STATE APPROVED
MOBILE HOME APPROVED (U.S. ONLY)
United States Stove Company
227 Industrial Park Road
P.O. Box 151
South Pittsburg, TN 37380
SAVE THESE INSTRUCTIONS
THIS MANUAL WILL HELP YOU TO OBTAIN EFFICIENT, DEPENDABLE SERVICE FROM THE HEATER, AND ENABLE YOU
TO ORDER REPAIR PARTS CORRECTLY. KEEP IN A SAFE PLACE FOR FUTURE REFERENCE.
851710 rev C
MODELS: 2000(L)(LN), 2500(L)(LN)
2000 Report #: 215-S-29-2
2500 Report #: 215-S-23-2
TESTED &
LISTED BY
PORTLAND,
OREGON, USA
For service questions, contact US Stove at 1-800-750-2723.
For sales inquiries, contact Sylvane at 1-800-934-9194 or visit www.sylvane.com.

Country Hearth 2500 Specifications

General

Type	Wood Stove
Efficiency	75%
Maximum Log Length	20 Inches
Flue Size	6 Inches
Material	Steel

Summary

Warranty Information Card

Tools and Materials Needed For Installation

Assembly Instructions

Blower Assembly

Details on installing the blower assembly to the rear of the stove.

Pedestal Trim Assembly

Instructions for assembling and attaching the pedestal trim pieces.

Ash Pan Assembly

Procedure for removing and installing the ash pan.

Installation

Safety Notice

Crucial safety warnings regarding proper installation to prevent house fires and ensure safe operation.

Positioning the Stove

Guidance on optimal placement of the wood stove for efficient heat distribution and safety.

Floor Protector Requirements

Clearances to Combustibles

Chimney Connector (Stove Pipe) Installation

Chimney Installation and Recommendations

Factory Built Chimney

Masonry Chimney

Combustible Wall Chimney Connector Pass-Throughs

Method A: 12-inch Clearance

Details for a 12-inch clearance pass-through using brick and clay liner with ASTM C315 compliance.

Method B: 9-inch Clearance

Details for a 9-inch clearance pass-through using factory-built chimney sections and air space.

Method C: 6-inch Clearance

Details for a 6-inch clearance pass-through using metal connectors and ventilated wall thimbles.

Method D: 2-inch Clearance

Details for a 2-inch clearance pass-through using solid-pak chimney sections and steel connectors.

Outside Combustion Air

Mobile Home Installation Requirements

Specific warnings and installation requirements for using the stove in mobile homes.

Woodstove Utilization

Testing Your Wood

Procedure to determine if wood is properly dried for efficient and safe burning.

First Fires and Operation

Ignition Procedure

Step-by-step guide for starting the stove, including chimney warming and initial fire building.

Heating and Combustion Control

Explanation of controlled combustion for efficient heating and how to adjust air controls.

Operation and Safety Warnings

Reloading the Stove

Instructions for safely reloading the stove with wood after the initial fire has established.

Creosote Management

Information on creosote formation, removal, and prevention to avoid chimney fires.

Ash Disposal and Maintenance

Ash Disposal Procedures

Safe practices for removing and storing ashes from the stove.

Glass Care and Replacement

Instructions for cleaning, inspecting, and replacing the stove's glass door.

Gasketing and Paint Care

Guidance on replacing door gaskets and maintaining the stove's paint finish.

Repair Parts Identification

How to Order Repair Parts