DAF LF45 Series Maintenance Schedule

MAINTENANCE SCHEDULE
2-2
©
200515
Maintenance activities
4
ΛΦ45/55 series
2.2 OVERVIEW OF ANNUAL MAINTENANCE ACTIVITIES
ANNUAL MAINTENANCE ACTIVITIES (Y-SERVICE)
"Correct, if necessary, after inspection"
CAB AND ELECTRICAL SYSTEM
O Check pedal rubbers
O Check whether the latest version of the ITS manual is kept in the cab
O Replace the cab filter element - See note 1 Replaced O Yes O No
O Check the fluid level of the cab tilting pump
O Check cab fastening
ENGINE, COOLING SYSTEM AND FUEL SYSTEM
O Replace the air filter element
O Check the air inlet dust trapping valve
O Check the vibration damper (vulcanised version)
O Check/adjust the valve clearance - See note 4 Done O Yes O No
O Check the coolant freezing point
O Change the coolant - See note 5 Changed O Yes O No
O Remove the fuel fine filter
STEERING GEAR AND BRAKE SYSTEM
O Check the steering ball joints
O Replace the air dryer filter element
O Check the brake cylinder fastening
O Check/adjust the load-dependent control valve
O Replace the steering gear filter element if the vehicle is equipped
with the RAS-EC system - See note 6 Replaced O Yes O No
O Replace the steering gear high-pressure filter if the vehicle is
equipped with the RAS-EC system - See note 6 Replaced O Yes O No
DRIVE AND CHASSIS
O Change the differential oil - See note 2 Changed O Yes O No
O Change the hub oil - See note 2 Changed O Yes O No
O Check operation of the differential lock
O Check the drive shaft play
O Check attachment of the clamp of the drive shaft universal joint
O Adjust the crown wheel guide bolt in case of a 5.12 rear axle
O Check for noticeable wheel bearing play in case of a 5.10, 5.12,
5.14 and 8.20 rear axle - See note 1 Done O Yes O No
O Change the gearbox oil - See note 3 Changed O Yes O No
O Replace the grease of grease-lubricated hubs, F36 and F48 front
axles - See note 1 Replaced O Yes O No
O Check the fifth wheel
O Check the trailer coupling
O Check superstructure attachment
O Lubricate according to Y-service lubrication schedule
OTHER ACTIVITIES
O Check whether there are any field actions that still need to be performed on the vehicle

DAF LF45 Series Specifications

General

Brand	DAF
Model	LF45 Series
Category	Trucks
Language	English