Daikin DPS015 - Performance Data Recording; Electric Heat Checks

IM 1125-7 • REBEL ROOFTOPS 106 www.DaikinApplied.com
WarranTy regIsTraTIon forM
Rebel Equipment Warranty Registration Form (continued)
13F-4157 (05/15) 3
Select Yes or No. If not applicable to the type of unit, select N/A.
IV. PERFORMANCE DATA (Unit to run at steady state for 15 minutes)
A. Discharge pressure, one compressor: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 _____ psig
B. Suction pressure, one compressor: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Circuit 1 _____ psig
C. Liquid temperature (°F): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
D. Suction line temperature °F from unit controller: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
E. Discharge line temperature °F from unit controller: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
F. Superheat temperature °F from unit controller: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
G. Sub-cooling line temperature °F from unit controller: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
H. Record discharge air temperature at discharge of unit (°F): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
I. Are all control refrigerant lines secure to prevent excessive vibration and wear? . . . . . . . . . . . . . . . Ye s No N/A
J. Are all valve caps and packing tight after start-up? . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . Yes No N/A
K. Did unit control DAT to DAT setpoint? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
V. Hot Water Coil
A. Pressure test OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ye s No N/A
VI. Heat Recovery
A. Heat wheel rotates freely? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
B. Heat wheel VFD operates properly? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ye s No N/A
C. Heat wheel VFD . . . . . . . . . . . . . . Model No. _________________________ Serial No. ___________________________
D. Check for air bypass around heat wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
VII. ELECTRIC HEAT
A. Electrical heat service corresponds to unit nameplate? . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
Volts _____________ Hertz _____________ Phase _____________
B. Are there any signs of physical damage to the electric heat coils? . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
C. Have all electrical terminals been tightened? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ye s No N/A
D. Does sequence controller stage contactors properly? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
E. Electric heater voltage across each phase: . . . . . . . . . . . . . . . . . ___________ L1 ___________ L2 ___________ L3
F. Amp draw across each phase at each heating stage:
Stage 1 Stage 2
Stage 3 Stage 4 Stage 5 Stage 6
Phase L1: ___________ ____________ ____________ ___________ ___________ ____________
Phase L2: ___________ ____________ ____________ ___________ ___________ ____________
Phase L3 ___________ ____________ ____________ ___________ ___________ ____________
G. FLA: L1 ___________ L2____________ L3 ___________
H. Operate electric heat with fans off. Electric heat must cycle on high limit control . . . . . . . . . . . . . . . Yes No N/A