Dea GHOST 200 Series User Manual

GHOST 200
Operating instructions and warnings
8
WARNINGToensureanappropriatelevelofelectricalsafety
alwayskeepthe230Vpowersupplycablesapart(minimum
4mmintheopenor1mmthroughinsulation)fromlowvolta-
gecables(motorspowersupply,controls,electriclocks,aerial
andauxiliarycircuitspowersupply),andfastenthelatterwith
appropriateclampsneartheterminalboards.
WARNINGInlinewithEUDirective2002/96/ECforwaste
electrical and electronic equipment (WEEE), this electrical
productmustnotbedisposedofasunsortedmunicipalwaste.
Pleasedisposeofthisproductbyreturningittoyourlocalmu-
nicipalcollectionpointforrecycling.
3 MODELS AND CONTENTS
OF THE PACKAGE
ThenameGHOST200 identifies a series of underground
electro-mechanicaloperatorswithdifferentfeaturesdepending
onmotorphasepowersupplyandspeed.
DEASystemarticlesintheseriesarelistedinthe“AVAILABLE
MODELS”table.
GHOST200iscompletedbyasetofaccessorieslistedinthe
“PRODUCTACCESSORIES”table.
Inspectthe“ContentsofthePackage”onPage30andcom-
pareitwithyourproductforusefulconsultationduringassembly.
4 OPERATING INSTRUCTIONS
IncompliancewithDirective2006/42/CEEnclosureI,Point
1.7.4.
4.1 Product description
GHOST200isanelectromechanicaloperatorforswingga-
tes(seeF1,page30)rotatinganarticulatedarm.
Thisarmisconnectedtothegatetobeoperatedbymeansof
theleverunitofthefoundationbox.Theleverunit,thatwillbe
properlyweldedatthetimeofinstallation,hasabuilt-inopera-
torunlockingdevicewhichwillallowyoutoopenthegateeven
ifthereisapowersupplyfailure.
4.2 Technical data
Seethe“TECHNICALDATA”table.
4.3 Labelling information
PartofthesummariseddatafortheCElabelarelistedinthe
labelappliedtotheproduct(seePositionF7,Page32);thedata
regardingtheseller are foundintheenclosedWarranty,whi-
le“IndispensableOperatingSafetyElements”arefoundunder
Point“4.2Technicaldata”.
4.4 Appropriate conditions of use
TheGHOST200isdesignedforinstallationincivilandindu-
strialswinggatesasanactuatorfortheoperationalautomatism
asshowninF3onPage31.Byinstallingtheaccessoryitem216
youmaywidenthewingangleofopeningupto180°.
TheGHOST200hasbeendesignedandtestedforopera-
tionunder“normal”civilandindustrialgateopeningconditions;
temperaturelimits,degreesofprotectionagainstdustandwater,
andotherdataareprovidedinPoint4.2“TechnicalData”.
Satisfactory operation requires the correct positioning of
theGHOST200operatorwithrespecttothegate(seeF4page
30).
Therequiredautomationmustbeselectedaccordingtothe
gatetobemoved;theattritionontheattachments,theweight,
thelength/heightofthegatewing,andthedegreeofclosing
of the surfaces are the elements to be considered. The chart
“LENGTH-WEIGHT”correlatingthelengthofthegateleafand
itsweightintypicalsituationscanbeusedinselectingtheauto-
mationaccordingtothegatetobeautomated.
“PRODUCT ACCESSORIES” table
Article
Code
Description
215
629000
Zinc-plated foun-
dation box with
release device
215 I
629010
Stainless steel
foundation box with
release device
216
629020
Device to be in-
stalled on item art.
215 and 215I to
get a 180° angle of
opening
218
629030
Mechanical stop
200 - 200CL - 200/EN - 200/CLEN 200L 200/24 - 200/24CL
Motor power supply voltage (V) 230V~±10%(50/60Hz) 24V
Absorbed power (W) 400 330 150
Max torque (Nm) 320 300 210
Duty cycle (cycles/hour) 20-28
(200/EN) 18 40
Maximum n° of operations in 24 hour 200 200 280
Built-in capacitor (µF) 12,5 -
Operating temperature range (°C) -20÷50°C
Motor thermal protection (°C) 150°C -
Opening time 90° (s) 17 26 16
Weight of product with package (Kg) 14,5 14
Protection degree IP67

Dea GHOST 200 Series Specifications

General

Brand	Dea
Model	GHOST 200 Series
Category	Gate Opener
Language	English