DLA 32cc - Page 42

GS R/C
DLA ENGINE OPERATING-INSTRUCTION
MANUAL
04-21-21 Copyrighted Material
Owner’s Manual All Rights Reserved 03180-10000
Page - 42 DLA 32, 58, 64, 64-I2, 116, 116-I2 & 128cc, 180c, 232cc Rev. A.05.15
DLA 116
Dwg
Key #
Part Description
STOCK
03180-01404
1
Cylinder Head, 58cc / 116 / 232cc, Straight Plug Configuration
IN
01380-01243 1S
Cylinder Head, 58 / 116 / 232cccc, Slanted Spark Plug Configuration
IN
03180-01406
3
Crank Case, Front & Rear, 116cc
IN
03180-00405 2 Crankshaft & Connecting Rod, 116cc IN
03180-01433 30 Key, Woodruff, 116cc IN
03180-01424 21 Propeller Shaft, Crankshaft Extension IN
03180-01434 31 Mount Base, Ring, Engine IN
03180-01418 15 Standoffs, Engine Mounting, 116cc (4 ea) IN
03180-01407
4
Piston, Wrist Pin & Retainers, 58 / 116cc (Piston Dia: 45.8 mm)
IN
03180-01408 5
Ring, Piston (DLA Factory), 58cc / 116 / 232cc IN
03180-01228 5B
Rings, BOWMAN, 58 / 116cc IN
03180-01222 4 Wrist-Pin, Piston, , Con-rod, 58 / 116cc IN
03180-01425 22 Retainers, Piston Pin IN
03180-01409
6
Ignition Module, Capacitive Discharge., 64 / 116 / 232cc
IN
03180-01413 10 Spark Plug, (All DLA Engines) IN
03180-01338 34 Plug Cap & Washer (1 ea) IN
03180-01427 24 Sensor, Ignition, w/mounting screws IN
01380-01239 41 Tachometer, (All DLA Engines) IN
03180-01410
7
Muffler, Std CAN, Left or Right, each, 116cc
IN
03180-01406 40
Muffler, Cannister, 58 / 116cc, 1-pc, Per Each IN
03180-01411 8
Carburetor, 116cc, Complete, Walbro WJ71 - 311 IN
03180-01414 11 Reed Valve Assembly, Carburetor, 116cc IN
03180-01435 32 Heat Block / Reed-Value Housing, 116cc IN
03180-01422 19 Mounting Base, & 4 ea Flat Head Bolts, Carburetor IN
03180-01439 36 Reed Valve, Only, 116cc Call
03180-01419
16
Hub, Propeller, Washer, Propeller, 116 / 116-I2cc
IN
03180-01429 26 Prop Wash, Only, 116cc IN
03180-01440 37 Prop-Hub, Only, 116cc IN
03180-01415
12
Bearing. Crakshaft Set, Front, Middle & Rear, 116cc
IN
03180-01420 17 Bearing Needle, Connecting-rod wrist-pin, 58 / 116 / 232cc, 13mm IN
03180-01412 all
Bolt-Set, Complete, 116cc 30-pcs, Per Set IN
03180-01428 25 Bolts, (Mounting Plat to Crankcase), Flat Head. (4 ea) IN
03180-01436 33 Bolts, Carburetor, (2 ea), Per set of 2 IN
03180-01416 9 Bolts, Muffler or Head, (All DLA Engines), 1-pcs , per each IN
03180-01438 35 Bolt-Set, Prop., 116cc, 4 ea, Per set of 4 IN
03180-01423 Bolt Set, Carb Mount Plate, Flat Head, 4-pcs, Per Set of 4 IN
03180-01421
18
Bolt Set, Crankcase, 4-pcs, Per Set of 4
IN
03180-01417 all
Gasket Set, All, 116cc, 8pcs, Per Ser of 8 IN
03180-01430 23/27/32 Gasket, Induction Stack, 116cc. (4 pcs), per set IN
03180-01426 23 Gasket, Carburetor, 116cc IN
03180-01432 29 Gasket, Cylinder Head, 58 / 116 / 232cc, 2-pcs, Per set of 2 IN
03180-01431 28 Gasket, Muffler, 58 / 116cc, 1-pcs, per each IN
03180-01443 44 Heat Shield Material, 50 sq-in IN
03180-01405 39 Air Filter, 90 deg, (All DLA Engines IN
DLA 116cc PARTS LIST - Rev: A.08
Functional
Groupings
Part Numbers - Engine Components
Prices Subject to Change without Notice on this Page
Heads
Crankcase
Crankshaft
Pistons
& Rings
IGNITION
Mufflers
Induction
Stack
Hubs
Bearings
Bolts
Gaskets