Gasoline is a highly flammable liquid. Gasoline also gives off flammable vapor that can be easily ignited and cause a fire or
explosion. Never overlook the hazards of gasoline. Always follow these precautions:
• Never run the Engine in an enclosed area or without proper ventilation as the exhaust from the Engine contains carbon
monoxide, which is an odorless, tasteless, and deadly poisonous gas.
• Store all fuel and Oil in containers specifically designed and approved for this purpose and keep away from heat and open
flame, and out of the reach of children.
• Fill the gasoline tank outdoors with the Engine off and allow the Engine to cool completely. Do not handle gasoline if you or
anyone nearby is smoking or if you are near anything that could cause it to ignite or explode. Replace the fuel tank and fuel
container caps securely.
• If you spill gasoline, do not attempt to start the Engine. Move the machine away from the area of the spill and avoid creating
any source of ignition until the gas vapors have dissipated. Wipe up any spilled fuel to prevent a fire hazard and properly
dispose of the waste.
• Allow the Engine to cool completely before storing the DR VERTICAL SHAFT ENGINE in any enclosure. Never store the
machine with gas in the tank or a fuel container near an open flame or spark, such as a water heater.
• Never make adjustments or repairs with the Engine running. Disconnect the Spark Plug wire and keep the wire away from the
Spark Plug to prevent accidental starting.
• Never check for an ignition spark with the Spark Plug or Spark Plug wire removed. Use an approved spark tester.
• Never tamper with safety devices. Check their proper operation regularly.
• Do not change the Engine governor settings or modify the Engine speed. Modifications will void your warranty.
• To reduce fire hazard, keep the Engine cooling fan and muffler area free of debris build-up such as leaves, grass, Oil, grease or
any other combustible material.
• Never operate the Engine without the muffler. Inspect the muffler periodically and replace if necessary. If equipped with a
muffler deflector, inspect the deflector periodically and replace if necessary.
• Never operate the Engine with the air cleaner or cover over the carburetor air intake removed, except for adjustment.
Removal of such parts could create a fire hazard. Do not use flammable solutions to clean air filter.
• Check fuel lines and fittings frequently for cracks or leaks, replace if necessary.
• Replace rubber fuel lines and grommets when worn or damaged and after 5 years of use.
• The muffler and Engine become very hot and can cause severe burns. Do not touch a hot muffler or Engine.
• Set the Engine throttle according to the recommendation of the owner's manual. Do not overload the Engine or run it with
low load and at low speed for long periods.
• Use specified grade of gasoline. The fuel should be clean with no debris. Keep the fuel opening clean and change the Oil
periodically.
• Periodically check that the Engine mounting bolts are tight. Tighten as necessary.
• Periodically clean the air cleaner element and change it when necessary.
• The Engine is air-cooled. Clean the top of the Engine and cooling fins to ensure optimum air flow.
• The operator should be familiar with the working principle and structure of the gasoline Engine, knowing how to make an
emergency stop and be familiar with using the controls. Anyone without training is forbidden to operate the Engine. Keep
periodical maintenance. Solve problems immediately. Do not run the Engine if it not operating properly.
To Next Page
Loading...
Need help?
General
