Duruxx DRX2 - Page 63

62
LUBRICATION AND
MAINTENANCE CHART
I: Inspect, verify, clean, adjust,
lubricate, replace if necessary
C: Clean
L: Lubricate
R: Replace
INITIAL INSPECTION 10 h or 30 days
EVERY
TO BE PERFORMED BY
25 h OR 750 km (470 m.)
50 h OR 1500 km (930 m.)
100 h OR 1 YEAR
OR 3000 km (1865 m.)
200 h OR 2 YEARS OR 6000 km (3730 m.)
DRIVE TRAIN
Front drive shaft
I
DE AL ER
Rear drive shaft
I
DE AL ER
Front output shaft
DE AL ER
Rear output shaft
I
DE AL ER
Wheel bearings condition
I
CUST O M ER
STEERING/CONTROL SYSTEMS
Steering wheel fasteners
I
DE AL ER
Throttle/housing/cable
➃
I
I
CUST O M ER
Choke condition
➃
I
I
CUST O M ER
Steering system
➂
I
I
DE AL ER
Tie rod ends
I
DE AL ER
Wheel nuts/studs
I
I
CUST O M ER
Wear/pressure of tires
➃
EVE RY DRIVE
CUST O M ER
Front wheels alignment
I
I
DE AL ER
SUSPENSION
Trailing arms
➃
I
DE AL ER
Shock absorbers
➃
I
DE AL ER
A-arms
I
CUST O M ER
BRAKE
Brake fluid front/rear ➃ I I
R
➄
C
UST O M ER
Brake pads
I
CUST O M ER
Brake system (discs, hoses etc.)
I
CUST O M ER
BODY/FRAME
Engine compartment
C
C
CUST O M ER
Frame
I
DE AL ER
Chassis fasteners
I
CUST O M ER
Seat fastener
EVE RY DRIVE
CUST OM ER
Vehicle cleaning and protection
C
CUST O M ER
➀
To be performed by an authorized Duruxx DRX2 dealer. The initial maintenance is very
important and must not be neglected.
➁
Every 100 hours, check coolant strength and pressure.
➂
More often under severe use such dusty area, sand, snow, wet or muddy conditions.
➃
Pre-drive
inspection item.
➄
To be performed by an authorized Duruxx DRX2 dealer.