E-TON Beamer R4 - Engine Controls; Manual Choke Lever Operation; Throttle Control Operation; Brake Systems Overview


8




ManualChokeLever
Thisscooterisequippedwithamanuallyoperated
carburetionchokesystem.Theenginechokeleveris
usedtoenrichthefuelmixturewhenstartingthe
enginefromacoldstart.

Whenfirststartingtheengine,(coldstart),placethe
leverinthefullleftposition,(Chokeclosedoron)After
allowingtheenginetowarmupfor15‐20
seconds,
slowlymovetheleverbacktotherightuntiltheengine
idlesdownrunssmooth.
Thelevertothefullrightisthenormaloperation
position.(Chokeopenoroff).


ThrottleControl
Thethrottlecontrolistheright‐handhandlegrip.
Throttleiscontrolledbytwistingthegrip.Thethrottle
controlisspringloadedandsetatthefactorytoreturn
totheidlepositionwhenpressureisreleased.

Toincreasethethrottle,twistthehandlegripina
counterclockwiserotation.Todecreasethrottle,twist
thehandgripinaclockwiserotationorreleaseyour
pressureandallowthethr
ottletoreturnonitsown.

Thethrottlecableshouldbeadjustedsothereis
5‐10mm,(¼"),freetravelofthet hrottlehandgrip
beforethethrottlestartstoopen.

Keepthethrottlecablelubricatedandoperating
smoothly.Ifthecablesticksorishardtooperate,
lubricatethecablebydisconnectingthecablefromthe
throttlehandgripandl
ubricatingwithacommercial
cablelubricantavailableatyourdealer.
Replacethecableifitshowssignsoffrayingor
corrosionoriskinkedorbent.

Toadjustthethrottlecable'sfreeplay,slidethe
protectivecoverdownthecabletoexposethecable
adjustingsystem.Loosenthelockingnu
tandadjust
thecablelengthbyturni
ngtheadjustingcollar.Check
thefreetravelinthethrottlehandgripuntilyouhave
5‐10mm,(
1/4")freetravel.Tightenthelockingnut
againsttheadjustingcollarandslidetheprotective
coverovertheadjustingsystem.

Replacethecableifthereisnoadjustmentremaini ng
ortheproperfreetravelcannotbeobtainedwiththe
adjustmentsystem.

BrakeSystems
FrontandRearBrakes
Thisvehicleisequippedwithfronthydraulicdiscbrake
andarearhydraulicdiscbrake.

Thefrontbrakeiscontrolledbythelongbrakeleveron
theright‐handlebar.Therearbrakeiscontrolledbythe
longleverontheleft‐Handlebar.

Copyright ©2008-2009 ETON America, all rights reserved.