Eco-King C99 - Page 9

77 pages

Save Page as PDF

To Next Page

To Previous Page

Part 1 – Introduction

Boiler dimensions

All dimensions mentioned in the figures below are in inches.

Main Page

Table of Contents2
Part 1 - Introduction4
Hazard Definitions4
For Your Safety, Read before Operating5
What to Do if You Smell Gas5
User Responsibilities7
Boiler Operation7
Manufacturer Conditions7
Installer Responsibilities7
When Servicing Boiler7
When Pressure Testing Boiler7
Main Parts10
Functionality of Main Parts11
Part 2 - Specifications / Technical Data12
Part 3 - Appliance Location14
Location Checks14
Appliance Area Ventilation Air Openings14
Closet Installations15
Alcove Installations15
Residential Garage Installations15
Prior to Wall Mounting16
Cold Weather Handling16
Wall Mounting16
Part 4 - General Venting17
Combustion Air-Intake Contamination17
Venting Options18
Concentric Installation19
Cut-Able Installation20
Installation of a Vent System Configuration with Wall Terminal22
Additional Instructions for Termination through a Wall with a Wall Terminal23
Mounting Instructions for Wall Terminal Installation23
Installation of a Vent System Configuration with Roof Terminal25
Additional Instructions for Termination through a Roof with a Roof Terminal26
Mounting Instructions for Roof Terminal Installation26
Mandatory Pre-Commissioning Procedure for Plastic Venting28
Vent/Air-Intake Pipe Length Determination28
Venting Rules and Guidelines29
Part 5 - Vent /Air - Intake Termination Clearances30
Part 6 - Condensate Drain37
Cleaning38
Part 7 - Central Heating (CH) and Domestic Hot Water (DHW) Circuit38
Frost Protection39
Vent Corrosion39
Vent39
Pressure Relief Valve39
Control Module40
Backflow Preventer40
Connect the Supply and Return Piping of the CH Circuit41
Connect an External Expansion Tank43
Installation Examples44
Part 8 - Installing Gas Piping48
Installation48
Ensure that48
Connecting the Gas Line48
Gas Pressure Regulator48
Part 9 - Electrical Connections Opening the49
Power Connection49
Connect the Room Thermostat49
Part 10 - Lighting the Appliance / First Start-Up51
Fill and Refill of the CH Section53
General Use of the Control Panel54
Setting of User Parameters54
Weather Dependent Control57
Set the Comfort Level58
Set the Maximum Central Heating Temperature58
Set the Hot Water Comfort58
Vent59
Diagnosis Menu60
Calibration62
Manual Calibration62
Automatic Calibration63
Service Operation63
Part 11 - Installation Check List64
Installation64
Start-Up64
Operational Checklist64
Before Leaving64
Instructions to Installing Contractor64
Part 12 - Annual Maintenance and Inspection65
Annual Inspection Checklist65
Crystalline Silica66
Refractory Ceramic Fibers (RFC)67
Part 13 - Parts List69
Automatic Air Vent70
Part 14 - Troubleshooting71
Servicing the Appliance71
Displaying Faults71
Fault History71
Fault Codes72
Reset Fault72
Trouble Shooting List73
Possible Causes and Solutions74
Part 15 Start up Checklist75
PART 16 Maintenance Checklist76
Inspection Activities76

Eco-King C99 - Page 9

Table of Contents