MAINTENANCE
29
• Plug the charger into a receptacle on a dedicated circuit. Do not connect any other devices to the receptacle.
• Connect the charger to the vehicle.
BATTERY CHARGING
The battery charger is designed to completely charge the battery set. If the batteries are severely deep cycled the
charger will indicate a fault. The automatic charger determines the correct length of charge for the battery set and
turns off when the batteries are charged. Always refer to the instructions supplied with the charger. See Appendix A
for charger operating instructions.
AC Voltage
The battery charger output is directly related to the input voltage. If the vehicle receives an incomplete charge in a nor-
mally adequate time period, low AC voltage can be the cause. Consult an electrician if necessary.
BATTERY PROLONGED STORAGE
Improper storage may damage, destroy or cause permanent loss of battery capacity. Do not exceed storage
time or temperature limits. Batteries must be charged to the correct level before storage. Storing fully
depleted batteries will make them permanently unusable.
Storage Preparation
The optimum storage temperature range is between 65°F and 82°F (18°C and 28°C)
• Charge the battery module based on climate during storage period.
– In cold climates, fully charge the battery module. Make sure that the charging operation is complete and there
are no faults displayed on the charger. The green light on the charger should be on indicating the charge cycle is
complete.
– In hot climates, store the vehicle with a 30% to 50% charge of battery pack capacity.
• Turn the key to the OFF position and remove it from the key switch.
• Check the run - tow switch under the seat, make sure it is set in the RUN position.
• Turn off all accessories.
The storage time for properly charged Lithium-Ion batteries supplied with this vehicle varies based on the ambient
temperature.
BATTERY FAULT DIAGNOSIS
Refer to the charger instructions in Appendix A.
Temperature Length of Storage Time
-22°F to -4°F (-30°C to -20°C) One month at 30%-50% battery charge, all accessories turned off.
-4°F to 113°F (-20°C to 45°C) Six months at 100% battery charge, all accessories turned off.
113°F to 140°F (45°C to 60°C) One month at 100% charge, all accessories turned off.
To Next Page
Loading...
Need help?
General
