FireplaceXtrordinair 42 ProBuilder GSB2 User Manual

42, 54 & 72
ProBuilder GSB2
Owner’s Manual
WARNING: FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Leave the building immediately
• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the fire department.
- Installation and service must be performed by a qualified installer, service agency or the gas supplier.
HOT GLASS WILL CAUSE
BURNS
DO NOT TOUCH GLASS
UNTIL COOLED
NEVER ALLOW CHILDREN
TO TOUCH GLASS
A barrier designed to reduce the risk of burns from
the hot viewing glass is provided with this appliance
and shall be installed for the protection of children
and other at-risk individuals.
Listed by
Omni-Test Laboratories, Inc.
Report # 0028GF105S
ANSI Z21.88-2016
CSA 2.33-2016
 Operation
 Maintenance
This appliance may be installed in an aftermarket, permanently located, manufactured home
(USA only) or mobile home, where not prohibited by local codes.
This appliance is only for use with the type of gas indicated on the rating plate. A conversion
kit is supplied with the appliance.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
French language manuals at fireplacex.com.
Manuels de langue Française à fireplacex.com
Travis Industries, Inc. 12521 Harbour Reach Dr., Mukilteo, WA 98275 www.travisproducts.com
 Copyright 2019, T.I. $10.00 4/22/21 100-01451

FireplaceXtrordinair 42 ProBuilder GSB2 Specifications

General

Brand	FireplaceXtrordinair
Model	42 ProBuilder GSB2
Category	Indoor Fireplace
Language	English

Summary

Introduction

Important Information

Details regarding serial numbers, purchase dates, and warranty registration.

Installation Warnings

Critical warnings and requirements for safe installation of the fireplace.

Features

Heating Specifications

Safety Precautions

Operation

Before You Begin

Instructions to read the manual and understand safety precautions before operating the fireplace.

Location of Controls

Identifies and explains the location and function of the fireplace's manual controls.

Starting the Fireplace for the First Time

Steps and considerations for the initial startup and curing process of the fireplace.

Turning the Fireplace On and Off

Instructions on how to manually operate the fireplace using the ON/OFF switch or optional remote.

Adjusting the Flame Height

Explains how to adjust the flame height and heat output using the flame adjust knob.

Adjusting the Blower Speed (Optional)

Details on how to adjust the speed of the optional blower for heat distribution.

Continuous Pilot / GreenSmart™ Pilot Switch

Explains the operation of continuous pilot versus intermittent (GreenSmart) pilot modes and reasons for switching.

Pilot Fuel Conservation Timer

Information about the 7-day pilot shutoff timer and strategies to manage its operation.

Normal Operating Odors

Explanation of odors that may occur during initial startup or after periods of inactivity.

Power Outages

Details on the battery backup system for power outages and battery replacement recommendations.

Maintenance

Glass Frame Removal and Installation

Step-by-step instructions for safely removing and reinstalling the fireplace glass frame assembly.

Crushed Glass Installation

Instructions on how to properly install crushed glass media onto the fireplace tray and burner.

Maintaining Your Heater's Appearance

Guidance on cleaning the fireplace glass and general surfaces.

Yearly Service Procedure

Recommended annual maintenance steps to ensure safe and efficient operation by a qualified technician.

Troubleshooting Table

Replacement Parts List

Lists part numbers for replacement components such as glass frames and barriers.

Wiring Diagram

Illustrates the electrical connections and components within the fireplace for servicing purposes.

Limited 7 Year Warranty

CONDITIONS & EXCLUSIONS

Details the terms, conditions, and specific exclusions that apply to the 7-year limited warranty.

IF WARRANTY SERVICE IS NEEDED

Outlines the procedure for initiating a warranty claim and obtaining service for the appliance.