Document Title Document No. Revision
Date Section
Supplement S3 to the AMM CTLS-LSA –
CTLS-LSA with ROTAX 912iS
AF 0480 0011 00 05-Aug-12 05-20-6
Approval Ref.: Approved on the Basis of Manufacturer Self Declaration
Inspection and/or Required Maintenance
Checklist
100hour
Annual
Other Times
Minimum
Level of
Certification
Initials /
Remarks
Refer to CHAPTER 78
▲Warning: Failure to inspect Muffler for leaks could result in Carbon monoxide entering the
cabin, leading to serious injury or death!
Firewall. Inspect for cracks, delamination,
buckling, and other signs of damage. Inspect all
items attached to firewall for security.
Inspect fire protection coat for condition, signs of
overheating and full coverage of firewall.
Pilot/Owner
Engine mount. Lift up the nose landing gear off of
the ground and inspect for deformation, cracks,
corrosion, damage from heat, loose hardware,
chafing by cables, wires, hoses, etc., and make
sure that any flexible item is secured to the engine
mount. Check mounting bolts for condition and
visual signs for loss of torque. If necessary check
correct torque value (see 200h).
Refer to Section 71-00.3.2
RLSA-M
Engine mount. Check mounting bolts for condition
and correct values.
At engine (4 bolts M10): 35 Nm
At shock mounts (4 bolts M10): 35 Nm
At firewall (6 bolts M8): 22.5 Nm
Replace safety wire where necessary
Refer to Section 71-00.3.2
200h
RLSA-M
Engine shock mounts. Inspect for porosity, cuts,
damage and deformations
Refer to Section 71-00.3.2
RLSA-M
Battery attachment. Inspect for security of
mounting and condition as defined in the basic
aircraft AMM. Ensure that the vent holes are clean.
Pilot/Owner
Starter. Check security of attachment and
electrical connections, as defined in the basic
aircraft AMM.
RLSA-M
Electrical wiring system. Verify the complete
electrical wiring system for security, damage, wear
and secure fit. Check all cable connections for tight
fit, good contact, corrosion and condition.
RLSA-M
Other engine external accessories. Inspect
screws and nuts of all other external engine parts
and accessories for tight fit.
Pilot/Owner
Foreign objects. Check the engine compartment
for foreign objects.
Pilot/Owner
To Next Page
Loading...
