forest river 2014 Flagstaff - Forest River Tent Camper Periodic Maintenance Chart

— 16 —
Tent Camper Owner’s Manual
fOresT riVer TenT Camper
p
eriOdiC mainTenanCe CharT
ITEM
EACH
TRIP
EACH
MO.
3 MO. 6 MO. YEARLY AS REQ. PROCEDURE
Fiberglass Exterior
•
Wash with warm water and mild detergent
•
Wax with liquid or paste wax
•
Check condition of body moldings and reseal as
needed
Tent Material
•
Clean and rinse thoroughly and allow to dry
•
Remove stains from vinyl with Oxy-Clean
•
Seal leaks in tent vinyl as required
Roof
•
Inspect and reseal as necessary
•
Lubricate roof vent mechanism with light oil
Windows and Doors
•
Clean windows with plastic polish used for auto
convertible top windows
•
Lubricate door hinges and step components with
WD40
•
Lubricate door locks and strike pocket, including
exterior storage and access doors
Seals and Adhesives
•
Inspect and reseal as necessary
LP Gas System
•
Check for leaks and road damage
Water and Drainage
•
Check hoses, ttings and connections for leaks or
signs of wear
•
Sanitize system and check fresh water inlet line
screen
•
Winterize system, if needed, due to weather
conditions
Electrical
•
Perform maintenance on converter per converter
manual
•
Check and service battery (if so equipped)
Appliances
•
Remove food and ice from refrigerator after each
trip
•
Check for obstructions and dirt on exterior appliance
vents
Safety Equipment
•
Check re extinguisher pressure and conditions
Wood Surfaces
•
Clean pre-nished panels and wood
Weight
and Distribution
•
Keep unit within specied load limits and proper
weight distribution
Lifter System
•
Lubricate
Bunks
•
Lubricate bunk slides with silicone
Axles
•
Mounting bolts should be torqued to specic foot
pounds
Wheel Bearings
• •
Repack wheel bearings
Brakes
• •
Check operation and for uneven wear
* As conditions and use warrant. (Follow instructions outlined in this manual.)