Fuso Canter 2015 - Rear Air Outlets

To Next Page

To Previous Page

9-3

Air outlets in vehicle equipped with rear heater

Rear air outlets

Z13164

FE_FG.book Page 3 Wednesday, December 4, 2013 2:10 PM

Main Page

Reading the Handbook5
Table of Contents6
Recommendation to Drivers8
Chassis and Engine Numbers9
Recommendation to Drivers9
- Vehicle Identification Number (VIN)10
- Maintenance11
- Periodic Inspection11
- DEF (Diesel Exhaust Fluid)15
- Handling of the New Vehicle20
- Maximum Engine Speed During Run-In Period20
- Obtaining Service21
- Reporting Safety Defects21
- Contact MFTA22
- Contact Your Nearest Authorized Dealer22
Warning Labels24
- Around the Driver’s Seat26
- Labels Inside the Cab26
- On Driver’s Door and Door Pillar27
- Exterior Labels28
- Opening and Closing30
- Starter Key31
Opening and Closing31
- Engine Immobilizer (Theft Prevention Device)32
- Doors35
- From the Outside36
- Central Door Locks37
- Keyless Entry System38
- Entering and Leaving the Vehicle42
- Door Window Glass44
- Power Window Switches44
Window Regulator Handle45
Seat and Steering Wheel Adjustments46
- Correct Driving Position47
- Driver’s Seat47
- Assistant Driver’s Seat48
- Making Adjustments48
- Rear Seat – Crew-Cab Models49
- Seat Belts50
  - Fastening51
  - Lap and Shoulder Belts with ELR51
  - Unfastening51
  - Lap Belt52
  - Seat Belt Anchor52
  - Children and Babies53
  - Pregnant Women53
  - Seat Belt Care53
- Steering Wheel54
- Switches and Controls56
- Arrangement of Switches and Controls57
- Starter Switch58
  - Starter Switch Position58
  - Acc59
  - Lock59
  - On59
  - Starter Key Reminder Alarm59
- Starting the Engine60
  - Pre-Starting Steps61
  - Starting Procedure62
  - Starting the Engine with the Cab Tilted64
- Warming up the Engine65
- Stopping the Engine67
  - Accelerator Pedal69
  - Brake Pedal69
- Pedals69
- Parking Brake Alarm70
- Parking Brake Lever70
  - Using the Parking Brake Lever70
  - Arrangement of Switches71
- Combination Switch71
  - Lighting Switch71
  - Exhaust Brake72
  - Lane Changer72
  - Passing Signal/Dimmer Switch72
- Turn Signal Lamp Switch72
  - Activation and Deactivation of Exhaust Brake73
  - Wiper and Washer Switch73
  - Before Starting the Engine75
  - Creep75
- Duonic75
  - Brake Pedal Operation76
  - Leaving the Vehicle with the Engine Running76
  - Parking76
  - Selecting the “R” (Reverse) Position76
  - Driving on a Slippery Road77
  - Starting on Uphill Roads77
  - Towing77
  - Controls and Indicators78
  - ECO Mode Switch78
  - Gear Position Indicator78
  - Gearshift Lever78
  - How to Operate the Gearshift Lever79
  - A/M: Automatic/Manual Shift Mode80
  - Gearshift Positions80
  - Reverse80
  - Driving Tips81
  - Automatic Shift Mode82
  - Starting82
  - Driving85
  - Reversing85
  - Driving in Automatic Shift Mode86
  - Driving in Manual Shift Mode86
  - Moving out of Mud, Snow or Sand88
  - Short Stops88
  - If a Transmission System Warning Is Displayed90
- Cruise Control92
  - Controls and Indicator93
  - Main Switch93
  - SET/RESUME Switch93
  - To Set a Desired Speed94
  - To Increase the Set Speed in Cruise Control Mode95
  - Automatic Deactivation of the Cruise Control96
  - To Accelerate Temporarily in Cruise Control Mode96
  - To Decrease the Set Speed in Cruise Control Mode96
  - To Reactivate the Temporarily Deactivated Cruise Control97
- Hazard Warning Lamp Switch98
- To Deactivate the Cruise Control98
- Front Fog Lamp Switch99
- Rearview Mirrors99
- Van Body Dome Light Switch99
- Mirror Heater Switch100
- Horn Switch101
- Transmission PTO101
  - Engagement102
  - PTO Switch102
  - Disengagement103
- Bluetec ® System104
  - DPF Cleaning Switch106
  - MODE Switch106
  - Multi-Information Display106
  - Regeneration Controlling DPF System106
  - PM Indicator107
  - PM Indicator and Warning/Indicator Lamp107
  - Automatic DPF Regeneration109
  - Parked DPF Regeneration111
  - How to Perform the Parked DPF Regeneration112
  - Warnings of Bluetec Exhaust Gas After-Treatment115
  - Warning of Abnormal Detection of DEF117
  - DEF Dosing System121
  - Muffler122
  - Instruments and Warning Lamps124
- Arrangement of Instruments and Warning Lamps125
- Speedometer125
- Tachometer125
- Water Temperature Gauge126
- Fuel Gauge127
- Quantity of Fuel Remaining in Tank127
- DEF Level Indicator128
- If the Tank Is Short of DEF129
- Multi-Information System130
  - Outline of Multi-Information System130
  - Display Mode Selection and Settings131
  - Odometer/Trip Meter131
  - Display Modes132
  - Calendar and Clock133
  - Date and Time Adjustment133
  - Date/Time133
  - Outside Air Temperature135
  - DPF Monitor136
  - Fuel Mileage Information137
  - How to Switch the Display137
  - Maintenance Information139
  - How to Set Replacement Intervals140
  - Maintenance Alarm Indication142
  - Resetting of Maintenance Information142
  - Illumination Intensity143
  - Selection and Adjustment of Illumination Intensity143
  - If There Are Multiple Warnings145
  - Indication Colors145
  - Telltale Indications145
- Warning/Indicator Telltale145
  - Red and Amber Indications146
  - Black Indications147
  - Engine System Warning148
  - Transmission Oil Temperature Warning148
  - SAM Warning149
  - Transmission Control Warning149
  - Amber Warning150
  - Engine Oil Level Warning150
  - Meter Cluster Warning150
- Warning/Indicator Lamps151
  - Vacuum Pressure Warning Lamp155
  - Brake Warning Lamp156
  - Charge Warning Lamp156
  - Engine Control Warning Lamp157
  - Engine Oil Pressure Warning Lamp157
  - ABS Warning Lamp158
  - Engine Overheating Warning Lamp158
  - Engine Immobilizer Warning Lamp159
  - When the Engine Can be Started159
  - When the Engine Cannot be Started159
  - Starting and Driving160
- Precautions When Setting the Vehicle in Motion161
Starting and Driving161
- Precautions for Driving162
- Tips for Improving Fuel Economy166
- Braking167
- Antilock Braking System (ABS)168
- On Uphill and Downhill Roads171
- On Rough Roads and in Bad Weather172
- Parking174
- Vehicles with Limited Slip Differential176
- Loading Cargo178
- Uphill Roads171
- How to Load Cargo179
8. 4WD Operation <FG Models180
- Control and Indicator Lamps for 4WD Operation181
- Front Drive Switch182
- Location of Control and Indicator Lamps182
- Selecting Drive Mode-Transfer Gear Range Combinations183
- Switching the Mode-Range Combination183
- Free-Wheeling Hub184
- Advice on Use of the 4WD Mode185
- Precautions to be Taken When Selecting the 4WD Mode187
- Heating and Air Conditioning188
- Front Air Outlets189
Heating and Air Conditioning189
- Rear Air Outlets190
- Manual Air Conditioner191
- Fully Automatic Air Conditioner197
- Outside Air Inlets202
- Rear Heater202
- Interior Equipment and Accessories204
- Cigarette Lighter205
Interior Equipment and Accessories205
- Ashtrays206
- Driver’s Door Ashtray and Assistant206
- Coat Hooks207
- Rear Ashtray in Crew-Cab Model207
- Sun Visors207
- Interior Lamp208
- Step Lamp209
- Small Article Compartments210
- AM/FM Radio and CD Player214
- Before Using the AM/FM Radio and CD Player214
- Using the Radio214
- Accessories237
11. in Cold Weather238
- Coolant239
- Engine Oil239
- Fuels239
- Other Recommendations for Cold Weather Operation240
- When Parking the Vehicle after Replenishing the DEF (Diesel Exhaust Fluid)240
- Installing Tire Chains241
- Simple Inspection and Service244
- General Precautions for Servicing the Vehicle245
Simple Inspection and Service245
- Engine Access Opening247
- To Reach the Access Opening247
- Power Steering Fluid and Engine Coolant Level Inspection Opening248
- Tilting the Cab249
  - Preparation250
  - Lowering the Cab252
  - Checking Locking of the Cab254
- Pre-Operational Checks255
  - Coolant Level256
  - Engine Oil Level256
  - Leak -Fuel, Oil, Coolant and Fluid256
  - V-Belt Tension and Damage256
  - Brake Fluid Level257
  - In the Driver’s Seat257
  - Parking Brake Lever Stroke257
  - Service Brake Pedal257
  - Gauge, Warning/Indicator Lamp Operation258
  - Lighting System258
  - Steering Wheel Free Play258
  - While Walking Around the Vehicle258
  - Battery Fluid Level259
  - Suspension Springs259
  - Wheels and Tires259
- Lubrication260
  - While Driving at Slow Speeds260
  - Grease Nipples261
- Greasing261
  - Recommended Lubricant264
  - Anchor Hooks265
  - Door Hinge265
- Oils and Fluids265
  - Checking267
  - Adding Oil268
  - Replacement268
  - Check, Addition, and Replacement270
  - Clutch Control Fluid270
  - Clutch Control Fluid Quantity270
  - Resetting the Engine Control Unit270
- Transmission Gear Oil271
  - Check272
  - Transfer Gear Oil274
  - Axle Housing Gear Oil276
  - Brake Fluid278
  - Adding Fluid280
  - Inspecting and Adding Fluid281
- Power Steering Fluid281
- Filter Elements282
  - Oil Filter Replacement282
  - If the Engine Is Cold283
  - Fuel Filter Replacement285
  - Air Cleaner Element Cleaning and Replacement290
  - Resetting the Dust Indicator291
- Draining Water from Fuel Filter294
- Engine Coolant - Check and Replacement295
  - Recommended Coolant296
  - Using Coolant Additive296
  - Water Used with Coolant296
  - Fuso Diesel Longlife Coolant298
  - Adding Coolant300
  - Adding Coolant During Pre-Operation Checks300
  - Adding Coolant Following an Engine Overheat300
  - Cleaning the Intercooler and Radiator Core304
  - V-Belts – Check and Adjustment304
  - Steering Wheel – Check306
  - Service Brakes – Check307
  - Steering Wheel Looseness307
  - Brake Pedal Play308
  - Brake Pedal Stroke308
  - Braking Performance308
- Parking Brake - Check and Adjustment309
  - Parking Brake Lever Stroke Check309
  - Inflation Pressure Check310
  - Standard Inflation Pressure310
  - Tires – Check310
  - Checking for Cracks, Damage, and Objects Embedded in Tread312
  - Checking Tread Depth312
  - Preparation for Tire Replacement313
- Tire Replacement313
  - Front Axle Jacking Points314
  - Rear Axle Jacking Point314
  - Removing the Wheel314
  - How to Remove a Wheel315
  - Mounting the Tire316
  - Wheel Nuts – Check and Retightening320
  - Dual Wheels321
  - Single Tire321
- Tire Rotation322
  - Replacing Blade Rubber Only324
  - Replacing Wiper Blade324
  - Wiper Blade – Replacement324
- Windshield Washer - Fluid Level Check and Refilling325
  - Battery – Check326
  - Removal and Installation of Battery Cover326
  - Inspecting the Battery327
  - Cleaning the Terminals328
  - Battery Removal and Installation329
  - Disconnect the Battery Cables329
  - Air Filters – Cleaning330
  - Outside Air Filter330
- Cleaning Your Vehicle331
  - Dashboard Air Filter331
  - Cleaning Glass Surfaces332
  - Exterior Cleaning332
  - Washing332
  - Dirt Caked on Paintwork335
  - Rust and Corrosion335
  - Small Chips and Scratches335
  - Waxing335
  - Cleaning Interior Trim336
  - General Dirt336
  - Interior Cleaning336
  - Cleaning Seat Belts337
  - Cleaning Vinyl Surfaces337
  - Organic Contaminants337
  - Other Contaminants337
  - Intercooler – Cleaning338
  - Removing Floor Mat for Cleaning338
  - Useful Advice for Emergencies340
- Possible Failures, Causes and Remedies341
- The Engine Does Not Start341
- The Starter Turns over Normally341
Useful Advice for Emergencies341
- Black or White Exhaust Gas342
- The Engine Fails to Stop342
- The Engine Overheats342
- The Engine Starts but Stalls Immediately342
- Engine Oil Consumption Is Excessive343
- Engine Oil Pressure Does Not Build up343
- Fuel Consumption Is Excessive343
- Braking Is Sluggish344
- Drive Power Is Insufficient344
- The Vehicle Pulls to One Side During Braking344
- Steering Is Difficult345
- The Lamp Does Not Light up345
- The Steering Wheel Doesn't Return to Straight Ahead Position Smoothly345
- The Steering Wheel Vibrates345
- Marking Your Vehicle346
- Stopping Your Vehicle in an Emergency346
- If the Engine Overheats347
- Repair347
- When a Fuse Has Blown349
  - Blade-Type Fuses350
  - Removal and Installation of High-Current Fuse Box Cover350
  - Inspection and Replacement of Blade-Type Fuses351
  - How to Remove the Spare Fuse352
  - High-Current Fuse355
- When a Lamp Has Burned out357
  - Headlamp Bulb Replacement359
  - Headlamp Removal and Installation359
  - Installing the Radiator Grille359
  - Headlamp Removal360
  - Headlamp Installation362
  - Front and Side Turn Signal Lamp Bulb Replacement365
  - Interior Lamp Bulb Replacement365
  - Replacing the Fog Lamp Bulb365
  - Replacing Other Lamps366
- If a Tire Goes Flat While the Vehicle Is in Motion367
- When Braking Is Sluggish367
- When the Battery Has Run down368
- If Fuel Tank Becomes Empty (Bleeding the Fuel System)370
- If the DEF Tank Becomes Empty370
- Towing371
- When the Vehicle Becomes Stuck in Soft Ground372
14. Service Data376
- Quantities of Lubricants/Hydraulic Fluids377
- Recommended Lubricants/Hydraulic Fluids and Quantities377
- Recommended Lubricants/Hydraulic Fluids378
15. Maintenance Schedule380
- For Maintenance Schedule in Severe Use381
- Lubrication Schedule388
16. Alphabetical Index392
Alphabetical Index393
17. Maintenance Record396
Steering System407

Fuso Canter 2015 - Rear Air Outlets

Table of Contents

Related product manuals