EasyManua.ls Logo

Generac Portable Products XG6500 - User Manual

Generac Portable Products XG6500
44 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
www.generac.com or 1-888-436-3722
Owner's Manual
XG Series 6,500-8,000 Watt Portable Generator
MODELS: 005796-0 (XG6500), 005797-0 (XG7000),
005798-0 (XG7000E), 005800-0 (XG8000),
005747-0 (XG8000E)

Table of Contents

Questions and Answers

  • N
    Natalie JonesAug 13, 2025
    What to do if my Generac Portable Products XG6500 Portable Generator engine will not start; or starts and runs rough?
    • J
      Julie MitchellAug 13, 2025
      If your Generac Portable Products Portable Generator's engine won't start or runs rough, there are several potential causes: * The fuel shut-off may be OFF - turn it ON. * The air cleaner might be dirty - clean or replace it. * The generator may be out of gasoline - fill the fuel tank. * The gasoline may be stale - drain the tank and refill with fresh fuel. * The spark plug wire may not be connected - connect it to the spark plug. * The spark plug may be bad - replace it. * There may be water in the gasoline - drain the tank and refill with fresh fuel. * The engine may be over-choking - put the choke knob to the No Choke position. * The oil level may be low - fill the crankcase to the proper level.
  • R
    Rebecca MoodyAug 17, 2025
    How to troubleshoot Generac Portable Products XG6500 Portable Generator when the engine is running, but there is no AC output?
    • G
      gregorygonzalezAug 17, 2025
      If the engine of your Generac Portable Products Portable Generator is running but there's no AC output, consider these possibilities: * The circuit breaker may be open - reset it. * There might be a poor connection or defective cord set - check and repair. * The connected device could be faulty - connect another device that is in good condition. * The GFCI may be tripping the 20 Amp outlet - repair the "short" and reset the GFCI.
  • A
    Amanda AdkinsAug 20, 2025
    Why does my Generac Portable Products XG6500 Portable Generator engine shut down during operation?
    • K
      kendralunaAug 20, 2025
      Your Generac Portable Products Portable Generator engine might shut down during operation due to: * Being out of gasoline - fill the fuel tank. * A low oil level - fill the crankcase to the proper level.
  • C
    Charles ChavezAug 25, 2025
    What causes a Generac Portable Products Portable Generator engine to lack power?
    • C
      Carl FreemanAug 26, 2025
      A Generac Portable Products Portable Generator engine may lack power if: * The load is too high. * The air filter is dirty - replace the air filter.
  • S
    sydney84Aug 28, 2025
    What to do if my Generac Portable Products Portable Generator engine runs good but bogs down when loads are connected?
    • K
      Kristy CruzAug 28, 2025
      If your Generac Portable Products Portable Generator engine runs well but bogs down when loads are connected: * There might be a short circuit in a connected load - disconnect the shorted electrical load. * The generator could be overloaded.
  • C
    Connie AndersonSep 1, 2025
    Why Generac Portable Products XG6500 engine will not crank?
    • A
      Anthony KnightSep 1, 2025
      If your Generac Portable Products Portable Generator engine won't crank, it could be due to: * A weak or dead battery - recharge or replace the battery. * You can start the engine manually using the recoil starter.
  • A
    Anthony HughesSep 4, 2025
    Why does my Generac Portable Products Portable Generator engine “hunt” or falter?
    • J
      John DelacruzSep 4, 2025
      If your Generac Portable Products Portable Generator engine "hunts" or falters, it could be because the choke is opened too soon - move the choke to the halfway position until the engine runs smoothly.
  • A
    Anthony WarnerSep 8, 2025
    What causes no battery charger DC output on my Generac Portable Products XG6500?
    • T
      Theresa SchneiderSep 8, 2025
      If there's no Battery Charger DC output on your Generac Portable Products Portable Generator, check for: * Corroded battery posts - clean them. * A bad battery cable - replace the cable. * A defective battery - check its condition and replace if necessary. * A melted Battery Charger in-line fuse (1.5A) - replace the fuse with an identical 1.5A replacement fuse only (located inside the control panel).

Generac Portable Products XG6500 Specifications

General IconGeneral
Generator TypePortable
Rated Watts6500
Starting Watts8125
Running Wattage6500
Engine Displacement389cc
Fuel TypeGasoline
AC Output120/240V
Voltage120/240V
Frequency60Hz
Wheel KitIncluded
Engine TypeOHV
Run Time at 50% Load10 hours
Outlets4x 120V 20A (5-20R), 1x 120/240V 30A (L14-30R)
Starting SystemElectric/Recoil

Related product manuals