Generac Power Systems 27 kW

Table of Contents
Owner’s Manual for Stationary Emergency Generators iii
Section 1 Safety
1.1 Introduction .......................................................................................................................... 1
1.2 Safety Information ................................................................................................................ 2
1.3 General Hazards ................................................................................................................... 2
1.4 Exhaust Hazards .................................................................................................................. 3
1.5 Electrical Hazards ................................................................................................................ 3
1.6 Fire Hazards .......................................................................................................................... 3
1.7 Explosion Hazards ............................................................................................................... 3
Section 2 Specifications
2.1 Emission Information .......................................................................................................... 5
2.1.1 Emissions Data Plate .................................................................................................................... 5
2.2 Specifications ....................................................................................................................... 6
2.3 Engine Oil Recommendations ............................................................................................ 7
2.4 Weather and Maintenance Kits ........................................................................................... 8
2.5 Coolant Water Treatment ....................................................................................................8
2.6 Fuel Requirements ............................................................................................................... 8
2.7 Reconfiguring the Fuel System .......................................................................................... 9
2.7.1 Fuel Conversion Procedure from NG to LPV ................................................................................9
2.7.2 Change Fuel Selection ............................................................................................................... 10
2.8 Battery Requirements ........................................................................................................ 10
2.8.1 Battery Charger .......................................................................................................................... 10
2.9 Corrosion Protection ......................................................................................................... 10
Section 3 Activation and Startup
3.1 Orientation .......................................................................................................................... 11
3.2 Remove Side Access Panels ............................................................................................ 11
3.3 Install Battery ..................................................................................................................... 12
3.4 Open Viewing Window ....................................................................................................... 12
3.5 Activate Unit ...................................................................................................................... 13
3.6 Start and Run Engine ......................................................................................................... 14
3.7 Operational Checks ........................................................................................................... 15
3.7.1 Self Test ......................................................................................................................................15
3.7.2 Check Manual Transfer Switch Operation ..................................................................................15
3.7.3 Electrical Checks ........................................................................................................................ 15
3.7.4 Test Generator Under Load ........................................................................................................16
3.7.5 Check Automatic Operation ........................................................................................................ 16
3.8 Final Instructions ............................................................................................................... 17
Table of Contents