TABLE OF CONTENTS
Page
GENERAL INFORMATION
we,m0Poky
SPECIFICATIONS
E_LU
S
INSTALLATION REQUIREMENTS
_meml 5
Prk:u'fo InlUlIikq
Smr_Wds/ncMx 66
N_um an_ LP O__F u_'Sx_ _m._m_
The Gen_alor a c ccnnedton Syl_
w_tngmconmcttom
_,o_dtng me_qto, e
ControlSys_m'n _ercertmmtam
Post Inimtdon k_Oeclk)n ! 0
POST INSTALLATION TESTS
Oem_aJ ! 0
Pf_ern_ _ _ _m_ Io
_ran_ S_ch Mmnuj O_m_n 10
"Vrans_WSwttOh Ek_'tlcal 'Tests 11
eene_m Tests I_ Lo_ 1I
OPE RATION
Using ihe Mlinua/-C)fl-Aufo 8wllch 12
0 Select Adonvnk: Ope_dcm 12
_KIu°_ °_ A_10mak: OPerllk_ 12
WeeMy E xe_cise Cycle !2
Eeect_oe Moisture w_, .,non _ t3
Eflo'-*'tsof HeM end Cold 13
c_ _, Req_m 13
MAINTENANCE
t3
t4
Change E _rm_ ON Firm f4
14
15
I__ smem Is
Tron_' SW_ M_ _n¢_ 15
S_om _ _S
Pl_e
ADJUSTMENTS
Oene_ 16
GIOeCmo Fuel Load BloOkAdluslmonl 16
v_i0e _ _q.mmm _?
PROTECTIVE SYSTEMS AND DEVICES
Oemn_
_'_eTem_m,,re a_Mo_
10
'Be
18
_e
_o
_e
TRO_SFKX)TING CHART 19
GENERATOR WIRING DIAGRAM 20
TRANSFER swrrcH WIRINCI DIAGRAM 21
ELECTRICAL FORMULAS 32
e 4
i
GENERAL INFORMATION
r'
- " " Equipment Descrl_lon
REPAIR PARTS
ExModedVlowo_(]Wwlo_ 22 Introduction
Elpkx_!
Vbw
oeTrllnl_
Swath
23 Th_ Owner s Ma_,el hae been ;xopa_ e_peoalty fo_Ire
Sell i1_ Pul_
equipm_ml RemdItte Ml_ud camf_ly ind comply w_t_al
mtruct'ons This will help Wevonl acd0enl or dav_a_e to
Exptoded View of V.Tw_ Englne ._ _ I_sl mlgh_ o_f_n_tse be caused by caro_ess
LIST OF ILLUSTRATIONS _very_ hasbeenexp_.xl_ to ensurethatme o_n_m_s
t3enm'Im_Modil_d9067TtlnM_Home8tw_,),Swt_hDtrner41o_sGNm_al°r 43 Qenm.i: resm"_m1her_t_l Iochange°_INs Mmnu_l Ire bo_ a_-_J_m anddlmoroff_erv_se.'n-curr°_lHovmmr
_3 The OImerItor Fu4#Sy|lem 8
IntMom'ln,_lon _ IDrllmdn_ No 74106) mad _ SAF_.TY RULES (Psge 1) €_r_lty _dl SAFETY
Figures The QeneiIlOr I-c Conneclton Sysiem 98 RULE S muef be etrt_ ¢'_ wllh. lo p_vlm_ ac_Idenl
Figure 7 BIftmy CIMe Conneclto_ RULES In INs Manu_. be lure to reed all In_ucllonl and
_$ Tmm#_ S_kc_ ManuwOp_mlon
_um9 C_r_ _ om_ _ mx,,_ to meequ4_me_
(S_ E_e_el 13
Figure 10 Genlmnlm Con#ol Panel Compomm_ 13 The !olowl_ d_lnllonl IlPl_ to DANGER, CAU TION Ind
_'tS_ 11 Englnl OI O_lk:lk & Fill Tube 14 HOTE MoOkl Iound IIl'oiJ_to_ Ihe ..M_
F_um 12 OID_n Hoee _4
Fl_uro 13 Engine O€ FiNer 14 DANGERP AFTLR THIn HEAOtNG" _LL IE I_OUNO_
F_jm ! 4 E_nglneAir _ Assembty 1S H&NOLING, INSTALLATION, OPIF.RAT',NG AND SER._
_J_e 15 GW_rll_r Loed Block VICING INS"RUCT_ONE THAT, IF NOT FULLY CO1_
Ad)uItment Poln_ !6 PLIED WITH. MAY RESULT IN PERSONAL INJURY ORJ
, ,, !
Ftgum 18 Oil Makeup Sy_em I 8 Inslilitm, qpeflltlng lind talcing InoUuctlofll IhIt_
Figure19Tempe_Mue_L°w O(i Pm_uurl/' H__Is.c_m 18 oqullmm_"noi elrtctty €omplle_ wllh, may n_ In damage ,€_
,_9 NOTE Afire. _ heed_ vdll be found ex_ocy siate-
FIgu_ 21 F_d _o_l C_o_ 19 ml,ntl thll mquke ipedl emph_lo
S_my wm'mgs canrm elnvn_e ths t_za_s mey tnd_
caw Strut cc,m_m wiremese wemlngep0ueoomm_
_mas we _ I _ n,_as_
sysWm _ to act as w_ eme_ge_'y _ o_
_ power m gle even( the UTILITY po_4K so_'ce hes
reded o_ has been reduoed to m unecmptal_ lev_
T_e syNl_ ll_kxltl I Itlndl_ _pm_Mo_ es(. encto,_<l e
an iI_ wNm_ _pilmonl **_*,:s_*. ,,_ w_t is a 100
am_ Wansk_ sw_t_ esasmoly Wh_ prol_e_y *_stile<l and
Inte_c_me_led. 1hesystem v,41i_ the UIILtTY pow_
supply voltage ShouM th_ scarce v_tage drop _ n
p'e-sm vllue autom_ _In_wui_' stlil_ and Wa_sf_ to
fl_ STANDBY pow_ _xwce w_ occur On rostOril_n ol
UTILITY _¢e _ to • _ (_) _v_ r_
tmrmlW back to I_e UTILITY source imd gen_rM_ Shul
dram wl occur
The ge_erlloe r_ be used to operlde 120 I,d/or 240
_#s. sm_giephaas, 60Hz. n-c ek_lrlc_ I_eds requr_g Up
to 8000 w11s (O0 kW) of _ power Compold)le
eklOlfl_d k)_ls requlrtng up to M 7 _t-c unperes al 120
vOfl$ Or up to 33 3 I-C B_tlNKqtSM 240 yogi may be
The transfer Sw_k:_Is riled 100 a-c amp_es al up to 250
vO#e The vw_fer switch is Inlended k_ indom mstaNetkon
_ _ code, _ _ _d_ _be_" beh_en
the _n_M_ _d UTILITY _w_ I_x_
Engln_GlnMMor D_ve Syllim
The 0e_eq_rs revo_ _ (Ro(o_) is d_*_ by a _n
€_Ik_ler englne, ll_m_0h i b_q randix_ey ;¥rang_mxml at
ni_ro,_'y 3eoorl_t "r_eengine_ _€._<_aay€_s_gm)d
equipped _ • sold ltMl (Ixeekede1_) _ system
ca_ kon cylndm' m, mnauton_l_ o41makeup sysI_n
and lu_xnI_ e_llne ixoleclve lhuldown devlc:es
NOTE Fm _ o_ the oll mem_p we_m _
IulomIIlC OrlglnoIXOkl'31_ IlilUldmm dlvt_ml. _lo AD-
D_NAL _FORMAT_N _ In INs
Acceel_ee
_ me generator we (,,) • 2 amp 8e._y
chwO_, (b)t_en_ r_, er_ (©)bem,rycoUasAtm_
le no( Indudod wllh I_e _nll A 12 voltl _ lype
r_edllto_ (Group 2t_). rated 36 imp-houre, is recom-
Testing Policy
Ange_r_ here bentac_r_ teetedaml a4ust_ using
rn_ce _ _to_ _ _ed_ Ou_
_ _ _ lebe_d onrectory _ts o_typi_i
_i_ w_€llum_)le_ to md Im_ _y m umude
_ _ndDew cm_nz mmlk4 by_e _gm men.at,
To Next Page
Loading...
