19
SERVICE INSTRUCTIONS
Air Cleaner
This unit is equipped with a foam-style air filter and should be replaced after every 20
hours of operating. Note: Operating in usually dusty conditions may require more
frequent replacement.
1) Remove air cleaner and cover by release the tab
2) Clean any excess dirt, oil, or dust from the air cleaner box with a mild detergent and
water solution.
3) Thoroughly dry the air box
4) Replace the air cleaner element.
5) Replace the cleaner cover.
Engine Oil
Initial engine oil is required to be changed in the first 5 hours of operating on a new
engine. The engine oil should then be changed every 10 hours of use thereafter.
1) Remove the drain plug located on the bottom of the right rear side of the engine.
Elevating the front of the kart slightly will help drain all the oil
2) Once the oil is completely drained, replace the drain plug and tighten carefully.
3) Place the kart back onto a flat surface to level the engine, and re-fill the crankcase
with 20 oz of SAE 10W30 motor four stoke oil.
4) Check the oil level using the dipstick attached to the oil fill cap. Be sure to check
the oil lever before each use of the kart. Add oil when necessary to keep the oil
level between the bottom of the dipstick and “O” mark.
To Next Page
Loading...
