Hayward SW1585X20 - User Manual

USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 1
PowerFlo LX
™
/ PowerFlo II
™
/ EP
Pump Series
Owner’s Manual
INSTALLATION, OPERATION, & PARTS
IMPORTANT SAFETY INSTRUCTIONS
Hayward Pool Products
620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995
www.haywardnet.com
Contents
Product Warnings……….………2
Installation……….……………..…4
Start-Up & Operation…….…….6
Shaft Seal Replacement……….7
Troubleshooting…………………..8
Replacement Parts………..….…10
Warranty …………………………..…11
Registration………………………….12
ISPFSERIES Rev G
Basic safety precautions s
h
ou
ld
a
l
ways
b
e fo
ll
owe
d
, inc
l
u
d
ing t
h
e fo
ll
owing: Fai
l
ure to fo
ll
ow instructions can
cause severe injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for
one of the following signal words and be alert to the potential for personal injury.
WARNING warns about hazards that could cause serious personal injury, death or major property
damage and if ignored presents a potential hazard.
CAUTION warns about hazards that will or can cause minor or moderate personal injury and/or property
damage and if ignored presents a potential hazard. It can also make consumers aware of actions that are
unpredictable and unsafe.
The NOTICE label indicates special instructions that are important but not related to hazards.

Summary

Important Safety Instructions

Suction Entrapment Hazards

Reducing Entrapment Risks

Steps to minimize risks associated with suction outlets and prevent entrapment hazards.

Separation Hazard Warnings

Electric Shock Hazards

Grounding and Bonding

Ensuring proper electrical grounding and bonding for safety against shock hazards.

Electrical System

Grounding, Bonding, and GFCI

Shaft Seal Change Instructions

Safety Precautions for Servicing

Essential safety steps before beginning shaft seal replacement, including power disconnection.

Troubleshooting

Motor Issues

Pump Priming and Flow

Hayward Pool Products Limited Warranty

Hayward SW1585X20 Specifications

General

Model	SW1585X20
Category	Water Pump
Horsepower	1.5 HP
Voltage	230V
Phase	Single Phase
Max Flow Rate	85 GPM
Wet End Material	Thermoplastic
Type	Swimming Pool Pump