Why is the alternator on my Hitachi Excavators noisy?
If your Hitachi Excavator's alternator is noisy, replace the drive belt if it's worn. If the pulleys are worn, replace both the pulleys and the belt. Adjust the alternator mount if the pulley is misaligned. Loosen the alternator belts and turn the pulley by hand; if you feel any roughness, the alternator bearing may be the issue.
What to do if Hitachi EX 3600-6 engine is not developing full power?
If your Hitachi Excavator engine isn't developing full power, start by checking the air and fuel filters; replace them if they're plugged. Inspect the fuel line for restrictions and repair or replace it as needed. Contaminated fuel can also cause this issue, so drain the fuel tank and clean the outlet screen. Ensure you're using the correct fuel and oil. Other potential causes include a plugged fuel tank breather (clean or replace it). If these steps don't resolve the problem, it is recommended to consult your authorized dealer.
Why does my Hitachi EX 3600-6 engine overheat?
If your Hitachi Excavator engine is overheating, begin by checking the coolant level and adding coolant if it's low. Inspect the radiator core and fuel cooler core for blockages, and clean them if necessary. A faulty radiator cap can also cause overheating, so install a new cap. Other possible causes include a damaged fan (replace it), a plugged air cleaner (clean it), or a loose alternator belt (tighten or replace it). Consider flushing the cooling system to clear any dirty passages. If these steps don't resolve the issue, further diagnostics may be needed.
What to do if Hitachi EX 3600-6 Excavators engine knocks, runs irregularly or stops?
If your Hitachi Excavator engine knocks, runs irregularly, or stops, first check the engine oil level and add oil if it's low. Ensure the air intake system isn't plugged by cleaning the filter and system. Also, bleed air from the fuel system to address potential water, dirt, or air contamination. Other potential causes include a malfunctioning fuel shut-off solenoid valve (clean fuel tank outlet screen). It is also possible that the coolant temperature is too low.
How to troubleshoot low engine oil pressure in Hitachi Excavators?
If your Hitachi Excavator has low engine oil pressure, first check the oil level and add oil if it's low. Inspect the oil filter for clogs and install a new one if necessary. Also, check for oil leaks. If the oil is diluted with fuel or coolant, check the cooling system. Ensure you're using the correct oil. If the engine temperature is too high, drain the oil.
How to fix Hitachi EX 3600-6 engine when it cranks but won't start?
If your Hitachi Excavator's engine cranks but won't start, several factors could be at play. First, ensure the emergency engine stop switch is off (set to NORMAL). Check if you're out of fuel and add fuel if needed, or that you're using the correct fuel. Contaminated fuel can also be a culprit, so drain the tank and refill with clean fuel. A low battery can prevent starting, so charge or replace it. Also, check and tighten battery and starter motor connections to rule out poor electrical connections. Other potential causes include a faulty starter motor (replace it), using the wrong engine oil (drain it), a plugged air filter (use correct oil), or a plugged fuel filter (replace elements). Low engine compression, leaks, or air in the fuel system can also be responsible; remove air from the ...
Why is an indicator light in the gauge panel inoperative on my Hitachi Excavators?
If an indicator light in the gauge panel of your Hitachi Excavator is inoperative, replace the bulb or the fuse. Do a sender check.
What to do if nothing works (except clock) on my Hitachi Excavators?
If nothing works on your Hitachi Excavator except the clock, replace the battery relay.
Why does the starter solenoid chatter on my Hitachi Excavators?
If the starter solenoid chatters on your Hitachi Excavator, clean the connections at the batteries or starter. Recharge or replace the batteries if the charge is low.
What does it mean if charging indicator light is on when Hitachi Excavators engine is running?
If the charging indicator light is on while your Hitachi Excavator engine is running, check the alternator belt for looseness or glazing. Adjust the engine RPM to the specified level. If you've added accessories, consider removing some or installing a higher output alternator. Inspect, clean, or tighten electrical connections on the battery, ground strap, starter, or alternator. Also, consider changing or replacing the battery.
Safe driving practices, including slope operation and obstruction avoidance.
Precautions to prevent machine tipping, especially on slopes.
Instructions on how to use the emergency escape device.
Daily pre-operation inspection checklist for the machine.
Step-by-step procedure for starting the engine correctly.
Safety measures and guidelines for operating the machine on slopes.
General guidelines for correct maintenance and inspection.
Safe driving practices, including slope operation and obstruction avoidance.
Precautions to prevent machine tipping, especially on slopes.
Instructions on how to use the emergency escape device.
Daily pre-operation inspection checklist for the machine.
Step-by-step procedure for starting the engine correctly.
Safety measures and guidelines for operating the machine on slopes.
General guidelines for correct maintenance and inspection.
General| Brand | Hitachi |
|---|---|
| Model | EX 3600-6 |
| Category | Excavators |
| Language | English |
To Next Page
