To Next PageTo Next PageWhy is auto-idle inoperable or not released on Hitachi ZAXIS 225US-5B?
If the auto-idle function is inoperable or not released on your Hitachi Excavators, it could be due to: * Faulty pressure sensor: Replace the pressure sensor. * Poor contact in connector: Repair or replace the connector. * Damaged wire harness: Repair the wire harness. * Faulty controller: Replace the controller.
What causes Hitachi ZAXIS 225US-5B Excavators batteries to discharge quickly?
If the batteries in your Hitachi Excavators discharge quickly after being charged, it could be due to: * A shorted cable: Repair or replace the cable. * A shorted battery separator: Repair or replace the separator. * Increased sediment in the battery: Replace the battery.
What to do if Hitachi Excavators starter rotates but doesn't start?
If the starter rotates but the Hitachi Excavators engine doesn't start, check for: * No fuel: Ensure there are no fuel leaks and refill the fuel. * Air in the fuel system: Bleed the air from the system. * Clogged fuel filter: Drain any water and replace the filter element. * Frozen fuel: Warm the fuel pump with hot water or wait for the temperature to rise.
Why do Hitachi Excavators batteries will not be charged?
If the batteries in your Hitachi Excavators are not charging, it could be due to: * A broken battery separator: Replace the separator. * A faulty regulator: Adjust and replace the regulator. * A faulty ground line: Repair the ground line. * A faulty alternator: Repair or replace the alternator.
What to do if Hitachi ZAXIS 225US-5B engine stalls soon after starting?
If your Hitachi Excavators engine stalls soon after starting, consider the following: * Too low idle speed: Repair the idle speed. * Clogged fuel filter: Drain water and replace the element. * Clogged pre-fuel filter: Clean or replace the element. * Faulty engine control system: Repair the engine control system. * Clogged air cleaner: Clean or replace the element. * Faulty injection pump: Repair the injection pump.
Why does the work mode not change on Hitachi Excavators?
If the work mode does not change on your Hitachi Excavators, it could be due to: * Faulty mode switch: Replace the mode switch. * Poor contact in connector: Repair or replace the connector. * Damaged wire harness (between MC and monitor): Repair the wire harness. * Faulty controller (MC): Replace the controller. * Faulty solenoid valve: Repair or replace the solenoid valve.
Why won't the Hitachi ZAXIS 225US-5B lever return to neutral?
If the lever on your Hitachi Excavators does not return to neutral, the cause may be: * Faulty pilot valve: Replace the pilot valve.
Why even if operating the engine control dial, the engine speed does not change in Hitachi ZAXIS 225US-5B Excavators?
If the engine speed does not change when operating the engine control dial in your Hitachi Excavators, it could be due to: * Blown fuse: Replace the fuse. * Faulty engine control dial: Replace the engine control dial. * Poor contact in connector: Repair or replace the connector. * Damaged wire harness (between EC dial and MC, or MC and ECM): Repair the wire harness. * Faulty controller (MC, ECM): Replace the controller.
Why does Hitachi ZAXIS 225US-5B Excavators travel speed does not change?
If the travel speed on your Hitachi Excavators does not change, it could be due to: * Faulty travel mode switch: Replace the switch. * Faulty pressure sensor: Replace the sensor. * Faulty pump 1 and 2 delivery pressure sensors: Replace the sensors. * Faulty pumps 1, 2 control pressure sensors: Replace the sensors. * Poor contact in connector: Repair or replace the connector. * Damaged wire harness: Repair the wire harness.
What causes Hitachi ZAXIS 225US-5B to not travel smoothly?
If your Hitachi Excavators does not travel smoothly, it could be due to: * Overly tensioned or slackened crawler sag: Adjust the crawler sag. * Lack of lubricant in front idler and/or roller: Refill lubricant. * Deformed track frame: Repair or replace the track frame. * Embedded foreign matter such as rock fragments: Remove the foreign matter. * Dragged parking brake: Repair the parking brake.
General| Operating Weight | 23, 700 - 24, 800 kg |
|---|---|
| Engine Power | 128.4 kW |
| Bucket Capacity | 0.51 - 1.2 m3 |
| Max Reach | 9, 960 mm |
| Max. Digging Reach | 9, 960 mm |
| Max. Digging Depth | 6, 670 mm |
| Fuel Tank Capacity | 400 L |
