Honda CR125R 2004 User Manual

HONDA O/M ’04 CR125R (E) (AH) 31KSR600
Honda CR125R
OWNER’S MANUAL
All information in this publication is based on the latest product information available at the time of
approval for printing. Honda Motor Co., Ltd. reserves the right to make changes at any time without
notice and without incurring any obligation.
No part of this publication may be reproduced without written permission.
 Honda Motor Co., Ltd. 2003
2004
*CR125R (E) COVER,HYO2 12/10/03, 2:47 PM2

Honda CR125R 2004 Specifications

General

Displacement	124.8 cc
Bore x Stroke	54.0 mm x 54.5 mm
Transmission	5-speed
Front Tire	80/100-21
Rear Tire	100/90-19
Ignition	CDI
Final Drive	Chain
Engine Type	Single-cylinder, two-stroke
Rear Suspension	Pro-Link Showa single shock
Front Brake	Single 240mm disc
Fuel Capacity	2.0 gallons

Summary

FUEL TANK

Fuel Tank Removal

Fuel Tank Installation

TRANSMISSION OIL

Inspecting and Adding Transmission Oil

Check and add transmission oil level following procedure.

Replacing Transmission Oil

Drain and refill transmission oil using correct procedure.

COOLANT

Cooling System Inspection

SPARK PLUG

Spark Plug Inspection & Installation

Inspect gap, electrodes, gasket, insulator, and install plug.

AIR CLEANER

Air Cleaner Cleaning Procedure

Wash air cleaner in solvent and soapy water, then dry.

Air Cleaner Assembly & Installation

CLUTCH

Clutch Disc/Plate Removal

Remove clutch springs, pressure plate, discs, and plates.

REAR BRAKE PADS

Brake Pad Wear Inspection

DRIVE CHAIN

Drive Chain Inspection

Drive Chain Adjustment

Loosen axle nut, adjust slack with adjusting bolt, tighten.

Drive Chain Removal & Cleaning

Remove master link, clean chain in solvent, inspect for damage.

Drive Chain Lubrication & Reassembly