Honda Goldwing GL1200L 1985 User Manual

13. Cruise Control
7. Igniticm
8. Lights/Switches/lnstrument$
9. Accessories
4. Engine RemovallinstaUation
114. Index
110. CFI System •
111. electronIc Travel Computer •
1
12
. Auto Leveling
Rear Suspension fEiI
I
16. Brakes
15. Frame/Suspension
13. Maintenance
12. Specifications
11. General Informatllm
Manual
infclf!11l3.tion, ilhJstr'sticlflS, directions and s~~ciflcatlorlS
included!n this are based on the product
lnf()rmaticm available at the time of approval for nrh'1tinln
Co" Inc. reserves the right to make changes
any time without without incurring any obliga-
tion whatever.
one
of sections 1·1 3 lists the contents of each sec-
tion and page references , Section 14 is an
overall index for this A Wiring is
located inside the back cover.
Sections 1·3 to the whole motorcycle, while sec·
tions 4-13 desoribe of the GL1 200L accor-
to Be sure to refer to the Maiinteinarlce
Schedule whenever
a 200L is brought In
service. Use the to know what the vehicle
needs to in condition and within EPA·
established standards, The first scheduled
eS~lecially imrlnrtAnt since it COlnpl:lnSistels
the break-in
In sections
10 1 "Service Information" follows
i"':nr\t~r\t!':' be sure to read those few lines before you
pro1cedlure to avoid any difficulty once you're in
the middle of a In most cases a reference draw-
will be
in Service Information, values are
in the metric standard newton-meters and also in
page 1·6 for a SPEICifiic e;Kplema-
tion of the use of metric equivalents.) A
trolubh:lshl001tina list follows the drawing,
and
then the service oroceejurEls
No of this put,'iclatioln may be re~lro(juc:edwi1:holiJt writ-
ten perml~lslon,
The GL1 200L Service Manual is divided into
14 sections. The first page of each section is marked with
a black tab that lines up with the tabs on this page, The
section on
the tabs also appear at the
of each page of the section
so you can to
where you want to be in the manual.
The service
in this SUI)pll~m,~nt are unique to
the 1 985 GL1 200L. In those instances the In-
terstate or model refer to
the base service manual.
About

Honda Goldwing GL1200L 1985 Specifications

General

Displacement	1182 cc
Starting System	Electric
Final Drive	Shaft
Front Suspension	Air-assisted telescopic fork
Rear Tire	140/90-16
Horsepower	94 hp @ 7000 rpm
Carburetion	4 x 32 mm Keihin
Ignition	Electronic
Transmission	5-speed
Rear Suspension	Air-assisted Pro-Link single shock
Front Brakes	Dual disc
Rear Brakes	Single disc
Front Tire	130/90-16
Fuel Capacity	22 liters (5.8 US gallons)
Fuel System	Carburetor

Summary

General Information

Service Safety

Provides safety precautions and warnings for servicing the motorcycle, emphasizing protective measures.

Model Identification

Details on identifying the specific motorcycle model, including visual references.

Emission Control Systems

Explains the motorcycle's systems designed to reduce emissions, including exhaust and crankcase controls.

Specifications

General Specifications

Provides key dimensional, frame, engine, and camshaft specifications for the model.

Standards and Service Limits

Lists critical component measurements, tolerances, and service limits for engine and chassis parts.

Torque Values

Specifies correct torque settings for engine, frame, and other components during assembly and maintenance.

Maintenance

Maintenance Schedule

Outlines recommended maintenance intervals and tasks based on mileage or time.

Fuel Filter

Instructions for inspecting and replacing the fuel filter.

Air Cleaner

Procedure for inspecting and replacing the air cleaner element.

Engine Removal/Installation

Engine Removal Procedure

Step-by-step guide for safely removing the engine from the motorcycle frame.

Engine Installation Procedure

Detailed instructions for reinstalling the engine into the motorcycle frame.

Frame/Suspension

Handlebar Replacement

Instructions for removing and installing the motorcycle handlebars.

Front Fork Illustration

Diagram illustrating the components of the front fork assembly.

Brakes

Front Master Cylinder Service

Procedures for the removal, disassembly, and installation of the front brake master cylinder.

Ignition

Ignition Service Information

Overview of the ignition system, including ECU control and component locations.

Ignition Troubleshooting

Diagnostic procedures for common ignition system faults and no-start conditions.

Ignition Timing Adjustment

Steps for checking and adjusting the engine's ignition timing.

Lights/Switches/Instruments

Lights and Switches Service Information

General information regarding the motorcycle's lighting and switch systems.

Lighting and Switch Troubleshooting

Diagnostic guides for common issues with displays, indicators, and switches.

Handlebar Switches

Inspection and testing procedures for handlebar-mounted switches.

Accessories

Fairing Lower Covers Service

Instructions for removing and installing the motorcycle's fairing lower covers.

CFI (Computerized Fuel Injection) System

CFI System Service Information

Overview of the CFI system, including its components and service precautions.

CFI System Troubleshooting

Diagnostic flowcharts and procedures for identifying and resolving CFI system faults.

Fuel Pressure Inspection

Steps for measuring fuel pressure in the CFI system.

Throttle (Øth) Sensor Service

Procedures for inspecting and testing the throttle position sensor.

Electronic Travel Computer

ETC Service Information

Overview of the Electronic Travel Computer system and service precautions.

ETC Troubleshooting

Diagnostic guides for common issues with the ETC display and functions.

Auto Leveling Rear Suspension

Auto Leveling Service Information

Overview of the auto leveling system and safety precautions.

Auto Leveling Troubleshooting

Diagnostic procedures for system operation issues, including error codes.

Air Distributor Service

Instructions for removing, inspecting, and assembling the air distributor unit.

Cruise Control

Cruise Control Service Information

Overview of the cruise control system and its operating conditions.

Cruise Control Troubleshooting

Diagnostic guides for common cruise control system faults and non-operation.

Throttle Operation and Adjustment

Guidance on checking throttle grip free play and performing adjustments.

Index