International Biomedical AirBorne 185A+ User Manual

107 pages

To Next Page

185A+ Transport Incubator

Service Manual

Table of Contents3
Language Disclaimer6
Section 1: General Information13
Introduction13
Classification13
Safety Summary14
Important Safety Considerations14
Symbols20
Model 185A+ Unpacking and Assembly21
Section 2: Set-Up Instructions24
Air and Oxygen Tanks24
Operational Check24
Section 3: Operating Instructions25
Front Panel Display Features25
Side Panel Features30
Power Features31
Powering up the Incubator33
Powering off the Incubator33
Display Modes34
Temperature Control34
Setting the Infant Chamber Air Temperature34
Pulse Oximeter and Oxygen Monitor Control (Optional Feature)35
Alarms / Indicators35
External Lighting38
Skin Temperature Probe38
Section 4: Pulse Oximetry (Optional Feature)39
Pulse Oximeter Principles of Operation39
Pulse Oximeter Set-Up Instructions41
Initial Set-Up41
SETTING HIGH and LOW %Spo 2 ALARMS41
Setting High and Low Pulse Rate Alarms42
Setting the Algorithm Mode (Masimo Only)42
Setting the Averaging Mode (Masimo Only)43
Setting the Perfusion Index (Masimo Only)44
Operational Alarms and Warnings44
Test of Operational Alarms46
Pulse Oximetry Sensors46
Pulse Oximetry Testers / Simulators47
Section 5: Oxygen Monitor (Optional Feature)48
Oxygen Monitor Principles of Operation48
Oxygen Monitor Set-Up Instructions49
Initial Set-Up49
Setting High and Low Oxygen Alarms49
Oxygen Monitor Calibration50
Operational Alarms and Warnings51
Test of Operational Alarms51
Oxygen Sensor52
Section 6: Preventative Maintenance53
Daily Maintenance53
Operational Check53
Air / Oxygen System54
Infant Chamber Check55
Cart and Accessories55
Sensors and Cables (Optional Equipment)55
Cleaning of Incubator and Chamber56
Cleaning of Cables (Optional Equipment)56
Cleaning of Pulse Oximetry Sensor (Optional Equipment)56
Cleaning of Oxygen Sensor (Optional Equipment)56
Monthly Maintenance57
Operational Check57
Keyboard / Led Check (Optional Feature)57
Alarm Mute Check (Optional Feature)57
Tank Inspection57
Infant Chamber Inspection & Cleaning58
Battery Test58
Air Flow System Inspection & Cleaning59
Hardware59
Battery Care60
Product Disposal / Recycling60
Section 7: Troubleshooting61
General Troubleshooting61
Main Display Error Codes62
Pulse Oximeter and Oxygen Monitor Failure Codes (Optional Feature)62
Section 8: Internal Component Access65
Electronics Compartment Access65
Battery Removal66
Control Board Removal66
Display Board Removal67
Pulseox Display Board Removal68
Pulse Oximeter Board Removal69
Section 9: Calibration Procedures70
Calibration Test Equipment Required70
System Calibration Procedure70
Control Board Calibration Procedure73
Display Board Calibration Procedure76
Section 10: Circuit Description77
Control Board77
Temperature Regulation77
Failsafe Temperature Limit78
Alarms78
Power Fail Alarm79
Voltage Reference79
Lamp Drive Circuit79
Battery Charger80
Power Source Selection81
Display Board81
Measured Temperature Display81
Main Incubator Alarm and Power Indicators82
Temperature Setpoint82
Setpoint Alarm82
PULSE, Spo 2 , and OXYGEN DISPLAYS (OPTIONAL FEATURES)82
Saturation, Pulse, Oxygen, and Pulse Graph Displays (Optional Features)83
Alarm and Power Indicators (Optional Features)83
Alarm Setpoints (Optional Feature)83
Setpoint Alarm (Optional Feature)83
Other Alarm and Warning Conditions83
General Mechanical Specifications84
Section 11: Specifications85
Electrical Specifications85
Operational Specifications85
Emc Specifications85
Essential Performance89
Pulse Oximeter Specifications (Optional Feature)90
Oxygen Monitor Specifications (Optional Feature)92
Operating, Storage, and Transport Environment93
Section 12: Warranty94
Section 13: System Documentation95
European Regulatory Affairs Representative95
Parts and Accessories95
Section 14: Schematics / Drawings96
System Wiring Diagram, Masimo Pulseox (002-0012)96
System Wiring Diagram, Nellcor Pulseox (002-0015)97
Control Board Schematic (001-5181)98
Pulseox Display Board Schematic (001-5193)99
Schematic, Non-Pulseox Display Board (001-5192)105
Temperature Sensor Resistance Values107

Need help?

Do you have a question about the International Biomedical AirBorne 185A+ and is the answer not in the manual?

International Biomedical AirBorne 185A+ Specifications

General

Brand	International Biomedical
Model	AirBorne 185A+
Category	Accessories
Language	English

Related product manuals

AirBorne NxtGen Transport Incubator

150 pages

International Biomedical AirBorne 185A+ User Manual

Table of Contents

International Biomedical AirBorne 185A+ Specifications

Related product manuals