Dead or damaged batteries must be disposed of properly. Refer
to 10.5.8 Recycling Batteries, page 87 for more information.
10.5.3 General Information on Battery Installation
WARNING!
Risk of Injury or Damage
Improper installation of the battery can result in injury
or damage.
-Batteries can weigh up to 52 lbs (23.6 kg). ALWAYS
use a battery lifting strap when lifting the battery. It is
the most reliable method of carrying a battery and
preventing serious injury.
WARNING!
Risk of Injury or Damage
Improper lifting technique may cause injury or
damage.
-Use proper lifting techniques, assistance and
gear such as straps when available when
lifting heavy loads.
WARNING!
Risk of Injury
Exposure to battery acid may result in injury.
-The use of rubber gloves is recommended when
working with batteries.
-DO NOT allow the liquid in the battery to come in
contact with skin, clothes or other possessions. It is a
form of acid and harmful or damaging burns may
result. Remove clothes that have been soiled by acid
immediately. Should the liquid touch your skin, wash
the area IMMEDIATELY and thoroughly with cool
water. In serious cases or if eye contact is made, seek
medical attention IMMEDIATELY.
-DO NOT install/reinstall a battery with a cracked or
otherwise damaged case.
Invacare strongly recommends battery installation and
replacement be performed by a qualified technician.
Read the installation instructions noted on the battery
and in the manual.
Ensure there is no battery acid in the bottom or
around the battery box or on the sides of the battery
(ies). Neutralize battery acid with baking soda if found.
Clean battery tray and batteries prior to installation.
Use battery lifting strap when available.
Keep batteries in an upright position and avoid tipping.
Use only deep cycle gel cell battery.
Use box wrench when tightening clamps. Do Not
wiggle the battery terminals/posts when tightening.
60101916-A 79
10 Service
To Next Page